6 CORPORATE PARKWAY
GOOSE CREEK , SC . 29445 STYLE NUMBER: KRA1713WT
www . quoizel . com
M Center Stem 1 pc
N Shade 1 pc H
I N
J
K
PREPARATION
● Before beginning installation of product, make sure all parts are present. Compare parts with package contents
list and diagram above. If any part is missing or damaged, do not attempt to assemble, install or operate the
product. Contact customer service for replacement part.
● Estimated Assembly Time: 20 - 30 minutes
● Tool Required for Assembly (not included): Flathead screwdriver, Phillips screwdriver, Pliers, Electrical tape,
Wire cutter, Safety glasses and (2) 100W A19 medium base bulbs .
● Helpful Tools (not included): Wire strippers.
1 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER: KRA1713WT
Outlet Box
Outlet Box Screw
STEP 2:
Use Wire Connectors (not supplied) to connect the
WHITE OR RIBBED WHITE OR RIBBED
wires.
a. Connect the House Ground Wire to the Fixture Ground FROM HOUSE FROM FIXTURE
Wire.
b. Connect the House White (or Ribbed) Wire to the
Fixture Supply Wire (Black or Smooth Side). BLACK (OR RED) WIRE BLACK OR SMOOTH
c. Connect the House Black (or Red) Wire to the Fixture FROM FIXTURE
FROM HOUSE
Supply Wire (Black or Smooth Side).
d. Wrap each connection with approved electrical tape
and carefully stuff all of the connected wires into the GROUND WIRE GROUND WIRE
Outlet Box.
FROM HOUSE FROM FIXTURE
STEP 3:
a. Place the Ceiling Canopy over the Mounting Screws
and secure with the Mounting Balls. Hand-tighten until Outlet Box
snug.
Mounting
Screw
Ceiling
Canopy
Mounting Ball
2 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER: KRA1713WT
STEP 4:
a. Screw the short nipple end of the Center Stem into the
Hickey underside of the Socket Cluster. Hand-tighten
until snug.
Socket Cluster
Hickey
Center Stem
STEP 5:
a. Place the Flat Washers, the Rubber Washers and the
Shade over the end of the Center Stem as shown.
Hand-tighten until snug.
Center Stem
Flat Washer
Rubber Washer
Shade
Rubber Washer
Flat Washer
1 / 8 IP Hex Nut
3 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER: KRA1713WT
STEP 6:
a. Place the Cap over the end of the Center Stem and
secure with the Finial. Hand-tighten until snug.
Shade
Center Stem
Cap
Finial
STEP 7:
a. Install correct bulbs referring to fixture markings and/or labels for maximum wattage.
Your installation is completed now. Restore electricity. Retain this sheet for future reference.
4 OF 4