Anda di halaman 1dari 12

General Information

Building Description
Attribute
Age (approximate) Area (approximate) Building type Single Family Multi Family Condominium Other - see comments Frame Brick Block Other - see comments

Job :

Description / Type

Address / Comments

Construction

Grounds
Comments
Slope away from house Driveway Porch Patio / deck Deck

Additional comments:

Utilities
Description
Water

Source / type
Public Deep well Point well See comments Natural gas Propane Fuel oil See comments

Comments

Gas / Fuel

Sewage

Public Septic tank and drain fill See comments

Weather at time of inspection


Temperature Start Time General Conditions

2000-2003 Best Inspectors Network,


Clearview Services Corporation

all rights reserved

www.msi.ms www.getitinspected.com/inspectors.html

Roof
Item / Attribute
Roof (structure)

Job:

Type / Style
Pitched Flat See comments

Condition

Comments

Good / Fair Warped Damage Unstable / Needs immediate repair Good / Fair Missing pcs. Damage Needs immediate repair

Roof covering

Shingle Membrane/ built-up / Roll Slate, Tile See comments zero to five years Greater than five years See comments Low, medium Steep Flat See comments Masonry Metal Stone NA / See comments Location/height acceptable

Remaining life Estimated

Slope

Chimney

Good / Fair Minor wear Unstable Damaged, missing, or broken cap / screen Location/height NOT acceptable Good / Fair Inadequate Damaged Missing pieces Good Fair Marginal Poor / Damaged

Gutters, downspouts

Metal Plastic See comments

Ventilation

Static Powered NA / See comments

Inspected from
Item / Attribute R R = Roof C = Chimney V = Ventilators C V Location Ladder Ground Roof See comments R C V Visibility Good Fair Marginal Poor
Comments

Additional comments

Note: red boxes indicating damage or items marked as needing immediate repair may result in further damage or may present a safety or health hazard if not repaired.
copyright 2000-2003 Best Inspectors Network, Clearview Services Corporation

all rights reserved

Exterior and Attachments


General
1 2 3 1 2 3

Job:

Covering

Brick Wood Block Vinyl / metal siding See comments Wood Metal See comments

Foundation

Concrete Block Brick See comments

Windows, Doors

Fascia, trim, Soffits

Wood Metal Vinyl See comments Tuck-pointing Paint ( trim doors windows siding ) Siding ( missing broken holes ) See comments

Water faucets

Tested Not tested See comments

REPAIRS NEEDED

Comments

Garages, Sheds, Out buildings


1 2 3 1 2 3

Garage / shed

Attached Detached Storage shed See comments


1 2 3

REPAIRS NEEDED

O.H. Door ( opener springs door ) Paint ( trim doors windows siding ) Siding ( missing broken holes ) See comments
1 2 3

Overhead door

Metal Wood Fiberglass See comments Tested Not tested


1 2 3

Floor

Good Minor/settling cracks Deep cracks See comments Tested Not tested / tested,Not working properly

Door opener

Safety eye

GFCI outlets*

Tested None / not working See comments

O.H. Door spring

Torsion (recommended) Extension (recommend replacing with torsion springs) Note:extension springs can present a saftety hazard if they are not properly maintained

Comments

The absence of GFCI electrical outlets is not a deficiency or defect. However, GFCI outlets are recommended for all outdoor outlets grade level access, garages, and workshop areas 2000-2003 Clearview Services Corporation, Best Inspectors Network all rights reserved

Interior living spaces


Item / Attribute
Floors

Job:

Type / Description
Sheet (Linoleum)/VCT (tile) Wood Carpet See comments Plaster, drywall Masonry Wood See comments Interior doors

Condition
Good Fair Uneven Damaged Good Minor cracks Damaged Unstable Good Fair Marginal Poor Good / Fair Need to clean Needs Repair

Comments

Walls / Celings

Doors

Fireplace

Masonry, brick Wood burner None Other / see comments

Attic
Item / Attribute
Access

Type / Style
Closet Hall Garage See comments Yes Partial None Fiberglass Cellulose None See comments None visible Damp, moist Fresh stains Old stains See comments Good Fair Marginal Poor Good Fair Marginal Poor
Tested Not tested

Comments

Floor

Insulation

Moisture

Whole house Fan

Additional comments

RED check boxes, when checked, indicate that attention is needed. Failure to attend to these items may result in damage or may create a hazard.
2003 Clearview Services Corp. all rights reserved

Kitchen
General
Item / Attribute
Floor

Job:

Type / Description
Sheet/VCT Wood Carpet See comments GFCI protected Not GFCI See comments

Condition
Good Fair Uneven Damaged

Comments

Electrical outlets in counter and sink areas

Good Fair Marginal Needs repair Good Fair Marginal Poor Good Fair Marginal Poor Good Fair Marginal Poor

Plumbing

No leaks visible Leaks visible Corrosion See comments Laminate Solid surface Marble/stone See comments Wood Other Damaged See comments

Counter tops

Cabinets

Comments

Note: RED check boxes, when checked, indicate that attention is needed. Failure to attend to these items may result in or create a safety hazard.

Abscense of GFI electrical receptacles does not constitute a deficiency or defect. However, GFI electrical receptacles are recommended in kitchen counter areas near the sink.
2000-2003 Clearview Services Corporation, Best Inspectors Network

all rights reserved

Bathrooms
Item / Attribute
Location

Job:

Type / Description Bathroom number 1 2 3 4 5


First floor Second Floor Master bedroom See comments

Condition

The number at the top of each column refers to the bathroom number.

1
Electrical outlets

5
GFCI protected Not GFCI* See comments

5
Good Fair Marginal Poor

1
Toilet

5
Std. gravity flush Pressure flush O.H. gravity flush See comments

5
Good Fair Marginal Poor

1
Plumbing

5
No leaks visible Leaks visible Corrosion See comments

5
Good Fair Marginal Poor

1
Shower / tub

5
Shower Tub Spa See comments

5
Good / Fair Needs caulk or grout Leaks Needs Repair

Additional comments
*Absence of GFCI electrical outlets does not constitute a defect or deficiency. However, GFCI outlets are recommended in all bathrooms.

Note: RED check boxes, when checked, indicate that attention is needed. Failure to attend to these items may result in damage or create a safety or health hazard. 2000-2003 Clearview Services Corporation, Best Inspectors Network all rights reserved

Plumbing
General
Item / Attribute
Main shut-off valve(s)

Job:

Type / Description
Supply side House side See comments No leaks visible Leaks visible Corrosion See comments

Condition

Comments

Good / fair Leaks Corrosion Unable to close Good Fair Marginal Poor Good Fair Marginal Poor

Piping

Soil stack (vent), drain

Sump pump

Yes No Backup system See comments


Electric Gas

Tested Not tested No cover Broken Good / fair Leaks Corrosion Replace Pressure relief missing / Incorrectly installed
Safety hazard!

Water Heater

See comments Pressure relief

Age (approx.)

Capacity

Additional Comments

Note: RED check boxes, when checked, indicate that attention is needed. Failure to attend to these items may result in damage or create a safety hazard.

2000-2003 Clearview Services Corporation, Best Inspectors Network. All rights reserved.

Heating and Cooling


Primary Heat Source
Item / Attribute
Heat source

Job:

Type / Description
Forced air furnace Gravity furnace Electric baseboard Boiler See comments

Condition

Comments

Good / fair Marginal Damaged Needs Repair / Missing pcs. Unable to test

Brand name Model Other Humidifier Yes No See comments Shut-off valve See comments Good / fair Leaks Corrosion Poor Good Fair Marginal Poor Good Fair Marginal Poor Good Fair Marginal Poor
i

Service piping

Flue piping

Plastic Galvanized steel mixed types See comments Sheet metal Flex duct Zoned See comments

Distribution

Primary Cooling System


Item / Attribute
System type

Type / Description
Whole house Window Other See comments

Condition
Good Fair Marginal Needs repair Unable to test

Comments

Number of units

Adequate See comments

Comments:

Additional comments
Note: RED check boxes, when checked, indicate that attention is needed. Failure to attend to these items may result in damage or create a safety hazard.
2000-2003 Clearview Services Corporation, Best Inspectors Network. All rights reserved

Electrical System
Service
Item / Attribute
Service location Brand name Main disconnects (#) System voltage Main overcurrent device Fuse Breaker Mixed types See comments

Job:

Type / Description

Condition
Good Fair Marginal Poor Good Fair Marginal Poor

Comments

Ampere rating Service entrance Overhead, cable Overhead, conduit Underground See comments Yes No See comments Good Fair Marginal Poor Good Fair Loose Broken

Bonding jumper on water meter

Made electrodes (ground)

Water line Ground rod See comments

Good Fair Loose Needs repair Tested Not tested

GFCI Breakers/ AFCI Breakers

See comments

Additional Comments:

Note: RED check boxes, when checked, indicate that attention is needed. Failure to attend to these items may result in damage or create a safety hazard.

Note: A representative number of devices were visually checked. Not all switches, light fixtures, outlets, and other devices
were checked. Overcurrent devices were visually checked but NOT tested. GFCI outlets are recommended in all bathrooms, basements, workshops, pool areas, garages, and outdoors where there is grade level access.

2000-2003 Clearview Services Corporation, Best Inspectors Network. All rights reserved

Basement, Utility, Crawl Space


Item / Attribute
Floor

Job:

Type / Description
Concrete Earth Earth w/ vapor barrier See comments Concrete Block Covered See comments Yes None visible See comments

Condition
Good Minor cracks Deep cracks Needs repair Good Minor cracks Deep cracks Needs repair Good Fair Rusted Needs repair Good Fair Marginal Poor

Comments

Walls

Floor drain

Moisture

None visible Damp / wet Stains Efflorescence See comments Steel Wood Concrete See comments

Support beam

Good / fair Sag/deflection Cracks Needs repair

See comments

See comments

Additional Comments:

2000-2003 Clearview Services Corporation, Best Inspectors Network .

All rights reserved

Summary

Job:

This document was created with Win2PDF available at http://www.daneprairie.com. The unregistered version of Win2PDF is for evaluation or non-commercial use only.

Anda mungkin juga menyukai