Mahmoud Ramadan I
Rem. Prosthodontics
502
Dr. Mahmoud Ramadan II
-:Thimbleshaped copings -1
.It may be placed on vital abutments →
Miller termed these abutment preparations "biologic stabilizers". He pointed out →
that even if the short life of the teeth, they might lend in helping the pt. become
.accustomed to denture wearing
There is an evidence of lessened resorption of the ridge tissues as none of the →
.dentures had required refitting
the occlusal surface is covered with gold casting so that, the loads of occlusion →
.would only be directed along the long axis of the abutment teeth
In case of restricted space, it is wiser to limit height of preparations to around →
4mm. (the walls of preparation must be parallel sided, otherwise a retaining post will
.(be required
.Inner copings cemented to the teeth need to be made of gold →
The outer copings forming part of the denture can be constructed in metal or →
.resin
Dr. Mahmoud Ramadan III
-:Disadvantages ☺
Space considerations often require devitalization of the abutment teeth. (root -1
.(canal treatment allows for great flexibility of treatment
.occupy considerable vertical& bucco-lingual space -2
coping must be covered with an adequate thickness of denture base material& -3
-:facing to
.a) Withstand loads& prevent breakage
.b) Provide a satisfactory appearance
The retention obtained from Over-denture will vary inversely with the taper of -4
.the coping
-:Indications ☺
.Pt. with partial anodontia -1
.Enough inter-ridge space is available -2
-:Domeshaped copings -2
-:Indications *
.Relatively small lateral loads applied to the roots -1
Where the root support nor vertical space permits the use of thimble copings or -2
.attachments
Cutting root filled teeth down& preparing dome-shaped copings to extend only 1 →
-:or 2mm above the ridge crest will produce
.a) Very significant improvement in the crown-root ratio
.b) Lateral load are reduced
.c) The space occupied is at a minimum
The roots are being used to give support against vertical loads, their contribution →
.to retention will be negligible
-:Denture stability depends on →
.a) Number& distribution of the roots
.b) The adaptation of the denture to the root preparation
Dr. Mahmoud Ramadan IV
Silver amalgam restorations are placed to seal the occlusal surface of the root →
.canal and the tooth surface& restoration polished
A gold coping with short retaining post is applied only when the acceptable →
.contour of the tooth surface can't be obtained
The absence of a coping simplifies the construction but topical application of a →
.2% sodium fluoride containing solution is recommended
-:The use of attachment -3
.Like Stud attachments, magnets, bar attachments →
.Attachments provide considerable retention& stability →
the space required is normally midway between the thimble copings& the →
.extremely short dome shaped preparations
the design& shape of attachments provide a significant measure of retention& →
.stability of over-denture
Adequate level of bone around the root is required to say nothing of sufficient →
space within the over-denture to accommodate he opposite section of the
.attachment and still provide enough strength for the denture base
Warren& Caputo felt that load distribution to the abutments might not be so →
.favorable when applied through attachments as with tapered copings
Attachments not only require precise location between the various components →
.but may place additional forces on their retaining posts
Diagram to show the vertical space requirements for the 3
types of root preparation