M-16 M-26
Air Temp Signal M-28 Coolant Temp Signal M-29 MAP Signal TPS Signal Trigger Signal (Crank) Sync Signal (Cam)
M-12
0-5v Analog Input or Thermistor 0-5v Analog Input 0-5v Analog Input or Thermistor 0-22v Analog Input Note: Use either VR or Hall Trigger Sensor M-32
VR Trigger Sensor
Sig
To +5v Sensor Supply, M-16 To +5v Sensor Supply, M-16 Note: Use either VR or Hall Sync Sensor Tachometer M-33
VR Sync Sensor
+
Sig
Tachometer Output Digital Output #1 Digital Output #2 Digital Output #3 Digital Output #4 Digital Output #5 Digital Output #6 Digital Output #7 Digital Output #8 Digital Output #9 Digital Output #10
M-17 M-11 M-02 M-19 M-21 M-05 M-07 M-22 M-24 M-25 M-06 Default Fuel Pump Control
Auxiliary Devices
Notes: - Digital Outputs can be used to control auxiliary devices. See manual for details. - Any Digital Output can be used for fuel pump control by configuring the software. Digital Output #10 is shown as an example. - All Digital Outputs pull to GND in the ECU when turned on.
Fuel Pump
20A Fuse Fuel Pump Relay Note: Size of fuse depends on total current draw of Digital Outputs and Injectors. A 20A fuse is sufficient for most applications.
Note: Use voltage supply from this location to power the Injectors and Digital Outputs on the 26-Pin connector Note: Use voltage supply from this location to power the Coils on the 26-Pin connector
Injector #1 Injector #2
M-03 M-10
Coil #1 Coil #2
M-01 M-04
10A Fuse
M-34 M-09 M-18
+12v Battery
12v Batt
WIRING DIAGRAM
The EDGE 34-Pin Main Connector
DRAWN BY
DRAWING FILE
BL
Pin 13
Pin 1
Pin 26
Pin 14
0-5v Analog Input 0-5v Analog Input 0-5v Analog Input 0-5v Analog Input To Additional Sensors
To +5v Sensor Supply, M-16 on 34-Pin Connector To +5v Sensor Supply, M-16 on 34-Pin Connector To +5v Sensor Supply, M-16 on 34-Pin Connector
Digital Input #7 is activated by pulling to GND C-09 C-20 C-21 C-22 Idle Control Stepper Motor
Coil #3 Coil #4
C-13 C-26
Coil #3 Coil #4
WIRING DIAGRAM
The EDGE 26-Pin Comm Connector
DRAWN BY
DRAWING FILE
BL