Tecaform (acetal resin) is a highly versatile engineering plastic with metal-like properties, it offers an excellent balance of desirable properties that bridge the gap between metals and ordinary plastics. Tecaform black machining is capable of CNC machining, CNC milling, CNC turning, and fabrication services. Since its introduction in 1960, acetal polymer has been widely used around the world in many application, such as in the automotive, appliance, hardware, electronic and consumer goods industries. Tecaform has gained widespread recognition for its reliability and performance in thousands of engineering components.
Properties and Characteristics Tecaform (POM-C) black acetal is known for its
High strength and stiffness (MOE 2600 MPa) compare to PA 6.0 (MOE 1600 MPa) Ease of machining (no microporosity) Dimensional stability (low moisture absorption 0,2%). Low coefficient of friction (0,35) compare to PA 6.0 (0,45). Low moisture absorption (0,2%) compare to PA 6.0 (9,5%) Low wear/ inherent self-lubricity Good electrical insulating characteristics because moisture has minimal effect of POM-C electrical properties (volume resistivity 1013 xcm) compare to PA 6.0 (because of high water absorption volume resistivity 1010xcm) Excellent resistance to gasoline, solvent, and many other neutral chemicals Better resistance to hot water and strong caustic high pH (basic) solution range of 5-9 Tecaform black is best suited for close tolerance mechanical parts. The added ethylene linkages of acetal copolymer increase the thermal stability, elongation,toughness and better impact properties
Mechanical
Wear surface : many types of bushings, bearings, cams Gears : spur, helical, bevel, worm Conveyors : flat top conveyor chain, conveyor links Pump impellers : submersible, gear, centrifugal Pistons Fan and blower blades Handles and knobs Pulley, casters, rollers
Electrical
Automotive switches and connectors Relay components Electrical switch components, buttons, and knobs
Environmental conditions
Salt water : marine fittings, fishing reels Fuels : gas caps, fuel senders/modules, filters Hot air : heater blowers, shower heads
Solvents
POM-C is exceptionally resistant to solvents retaining over 90% of its tensile stress after exposure to almost all solvents. Lubricants and Hydraulic Fluids. POM-C generally has good resistance to base oils. The presence of chemical additives in some oils may have a marked effect on performance, particularly at temperatures above 66C.
Gasolines
Tensile strength of Delrin acetal resin is essentially unaffected by exposure to gasoline. Stiffness can be reduced a moderate amount, depending upon the concentration of aromatic hydrocarbons in the fuel. This slight plasticizing effect is completely recoverable if exposure is terminated and the hydrocarbons allowed to evaporate
Data Properties
TECAFORM AH ( POM-C )
Effect of moisture on tensile properties of reinforced nylon 6 (33% glass fiber) : tensile strength and strain at yield vs. moisture at room temperature
Impact of temperature and moisture on tensile strength of reinforced polyamide 6 (33% glass fiber)
sources :BASF Corporation 3000 Continental Drive North Mount Olive New Jersey 07828-1234 www.basf.com/usa
www.sugison.com
Source : Top Ten Design Tips- a series of 10 articles. Hasenauer.J.; et.all . Dupont.
THANK YOU
www.sugison.com www.grahamika.indonetwork.co.id E : hudi.leksono@sugison.com