Revision 1.0
April 2002
Table of Contents
DeskJet 3300/3400 Disassembly Procedure ............................................................................................ 1 A. Required Tools:..................................................................................................................................... 1 B. Removing the Case Parts: ................................................................................................................... 2 C. Removing the Carriage Mechanism: ................................................................................................... 4 D. Removing the Paper Pick Assembly:................................................................................................... 6 E. Removing the Capping Station: ........................................................................................................... 8
Page 1 / 10
3. With the access door halfway open, pull the access door from the two hinges.
5. Remove the Input Extension from the Out-tray by pressing inwards at the center until the extension tab snaps out from the intray.
Page 2 / 10
6. Remove the cleanout assembly by pressing the tab towards the center of the printer and pull out the rear access door from the printer.
Page 3 / 10
3. To remove backbone from the printer; lift and rotate the backbone assembly from the left wall until the left front corner of the backbone is displaced from the sheet metal tab.
Page 4 / 10
4. While resting the backbone assy the base unplug the Carriage Motor Cable connector from the Logic PCA,
5. and then use needle nose pliers to unplug the flex cable connector from the Logic PCA
Page 5 / 10
2. To remove the Wiper Sled push the wiper sled forward with your fingers and at the same time using a small screwdriver to lift the front section until it clears off the base structure.
4. Unlock left bearing from the left wall and remove the screw from the right wall
Page 6 / 10
5. Lift the Paper Pick Assembly from the printer chassis, and check that the Service Drive Gear is disconnected from the Wiper Shift Plate.
Page 7 / 10
Page 8 / 10