http://boilerdetails.blogspot.in/2010/07/boiler-turbine-turbogenerator-i...
Boiler Tube Leakage Furnace Explosion Clinker Formation in Thermal Power Plant Boiler
Avoid clinker formation, use acoustic Instruments to detect early boiler tube leakage, avoid Boiler Furnace Explosion by timely purging, Facts about efficient running of boiler and thermal powe plant.
Home
Boiler Turbogenerator GT ESP ABT FSS Deaerator Scanners Soot blowers Air heaters Economisers Superheaters Reheaters ID FD PA Fan BFP LPH HPH CW Pump
Introduction and some facts about large thermal power station for efficient operation.
Ball Mill or Bowl mills are used for pulverisation of coal in powder form for efficient firing in boiler.
Raw Coal Feeders are used to supply coal to ball mills in controlled quantity.
ID Fan is used to exhaust flue gases to chimney and create vacuum in Furnace.
6,568
Electrostatic Precipitators are used to separate ash particles from flue gases to control pollution. Here collecting electrode emitting electrode and rapping mechanism used.
Steam produced in boiler is further superheated in Super heaters. There are lot super heaters such as platen, pendent, convection and final super heaters.
Climate Change Will Turn Off the Lights: Ne CleanTechnica In the near future, power potential is expect to be reduced from 4 to 16%, with the possibility of a complete system collapse tripling or more. Power plants that use heat produce electricity are thermal power This includes nuclear, coal, ...
Boiler drum used for separation of steam from water and storage. Nowadays drum less once through boiler also used which operates at super critical temperature and Pressure.
Boiler circulation pump used for forced circulation of water in water wall because at high pressure natural circulation is not possible.
Soot Blowers used to remove soot from water wall, Super heater, Re heaters and Air Heaters by injecting steam into heating surfaces.
NTPC begins work on power project in New York Daily News Bangalore, June 2 State-run National Thermal Power Corporation (NTPC) Ltd Saturday commenced work on the first phas of the 4000 megawatt super thermal power plant in Karnataka's Bijapur district. Union Power Minister Sushilkumar Shinde Saturda ...
1 of 3
6/5/2012 6:48 PM
http://boilerdetails.blogspot.in/2010/07/boiler-turbine-turbogenerator-i...
Economic Times NEW DELHI: State-owned BHEL today said has bagged a Rs 1143 crore contract from country's largest power generation utility NT for setting up a 500-MW power generating at its Vindhyachal Super Thermal Power Station in Madhya Pradesh.
ESV which is called emergency stop valve used to stop supply of steam to turbine when unit trips.
Re heaters used to reheat steam exhausted from HP turbine. After reheating up to 535 degree centigrade same steam is utilised in Intermediate Pressure Turbine.
Power ministry sets up panel to analyse los Times of India Shinde laid the foundation stone for the civil works for the turbines and boiler National Thermal Power Corporation's (NTP 1320 MW super critical thermal power Phatate Wadi some 18 km from Solapur city The Rs 9395-crore plant will ... Related Articles
powered by
Barring gear or shaft turning gear is used to rotate turbine rotor at 3.15 rpm when turbine is not running to check bending of rotor due to its own weight.
Thermal Power Plant
LP Heaters and HP Heaters are used to heat condensate and feed water supplied to boiler to increase efficiency by steam bled from turbine extraction.
Economiser is used to heat feed water by flue gages to increase efficiency. Heat of waste flue gas is utilised here.
Air Heaters uses heat of waste flue gases to preheat primary and secondary air. There are two types of air heaters tubular and rotary.
Condensate Pump are used to supply water to De aerator from condenser Hot well.
Raw Water is circulated by cw pump into condenser tube hence leakage from condenser tubes must be checked to avoid mixing of raw water into Hot well.
Blog Archive
2011 (1) H2 Gas used in generators used for cooling of generators. 2010 (6) September (2) Seal Oil system used to seal hydrogen gas from escape from generator. July (4) Acoustic Monitoring Instruments for Boiler tube le... Stator Water Cooling system provides demineralised water into hollow stator conductor of generator for its cooling. Superheater Waterwall Economiser Tube Leakage may ... Boiler Turbogenerator GT ESP ABT FSS Deaerator Sca... Avoid Clinker Formation in Boiler using good quali... 2008 (8)
Water Treatment Plant is used to produce demineralised water for steam generation. Cation anion and degasifiers tower used to separate mineral and gases from water.PAC or alum used to separate mud and silica from water. Here minerals removed from water and ph value is maintained near 7 and silica value must less them 0.02 ppm
Coal Handling Plant supplies Coal to Boiler. Merry go round system or wagon tippler used to unload coal into hoppers. Coal is crushed in crusher to crush it in 25mm size. Magnetic separators used to separate metallic particles from coal.
ABCB, SF6, OCB, MOCB and VCB are circuit breakers used to make or break electricity contact at load.
powered by
Purging is done to clean furnace from combustible gases by running ID Fan and FD Fan at least 30% load for 5 minutes to avoid furnace explosion.
Furnace explosion may be checked by timely purging and adjusting firing properly using right quantity primary and secondary air and timely oil support and avoiding leakage of fuel oil in boiler. Furnace must be purged properly again if flame is not established during light up of boiler.
Flame scanners used to sense flame in boiler to detect flame failure to avoid boiler furnace explosion.
Clinker formation which caused by more ash content having low fusion temperature and mineral in poor quality coal may be checked by proper poking and using more water for flushing and use of clinker grinder and regular soot blowing. Over firing which is also cause of clinker formation may be avoided by proper primary and secondary air ratio.
Acoustic Instruments used to detect early boiler tube leakage to avoid secondary damage to pressure parts, Refractory and structures of Boiler. Boiler must
2 of 3
6/5/2012 6:48 PM
http://boilerdetails.blogspot.in/2010/07/boiler-turbine-turbogenerator-i...
be immediately shut down in case of Boiler tube Leakage. http://tpp-4u.blogspot.com/ Posted by writer at 7:19 AM
Tag Cloud
Electrical Jobs
Treatment Water
Water Treatments
0 comments:
Post a Comment
Newer Post
Home
Older Post
ESP
Follow by Email
Email address...
3 of 3
6/5/2012 6:48 PM