2.
COMPOSITION/INFORMATION ON INGREDIENTS
COMPONENT LISTING: _____________ Chemical Name DIMETHYLPOLYSILOXANE MISCELLANEOUS: Listed on the TSCA Inventory. No hazardous materials present. EXPOSURE GUIDELINES: No Information Available. ________ Amount 100.0 % __________ CAS Number 63148-62-9
3.
HAZARDS IDENTIFICATION
***************** EMERGENCY OVERVIEW ***************** * * * No hazardous materials present. * * * **********************************************************
4.
EYE CONTACT FIRST AID: Immediately flush with water for at least 15 minutes. SKIN CONTACT FIRST AID: Remove product from skin with dry cloth or towel, and wash exposed area with detergent. INGESTION FIRST AID: Wash out mouth with water provided person is conscious. Never give anything by mouth to an unconscious person. Call a physician immediately.
5.
N/A
6.
7.
8.
9.
10.
11.
TOXICOLOGICAL INFORMATION
EYE EFFECTS: May cause transitional slight eye irritation. SKIN EFFECTS: Patch test (24Hr/Open): Negative (1%).
ACUTE ORAL EFFECTS: LD50 (Oral/Rat): >5g/kg (estimated by similar dimethylpolysiloxane). CARCINOGENICITY: NTP: Not listed, IARC: Not listed, OSHA Regulated: Not listed.
No evidence of carcinogenicity in laboratory animals. MISCELLANEOUS: Not applicable (LC50). No evidence of subacute toxicity in rats or mice. This product can generate formaldehyde at approximately 150 degrees C
(300' F) and above in the presence of air. Formaldehyde is a skin and respiratory sensitizer, eye and throat irritant, acute toxicant and potential cancer hazard. So, use adequate ventilation or wear protective equipment such as gloves, goggles or protective clothing when this product is heated at approximately 150 degrees C (300' F) and above in the presence of air.
12.
ECOLOGICAL INFORMATION
ENVIRONMENTAL DEGRADATION: No evidence of biodegradation. MISCELLANEOUS: No evidence of bioaccumulation. No ozone depleting materials (CFCs, HALONs and HCFCs) are present and used in manufacturing. May cause decomposition in soils.
13.
DISPOSAL CONSIDERATIONS
DISPOSAL: Observe all federal, state and local laws. container unlawfully. Do not dispose of emptied
14.
TRANSPORT INFORMATION
PRODUCT LABEL ...: Fuser Oil Unit Type P
15.
REGULATORY INFORMATION
MISCELLANEOUS INFORMATION: Listed on the TSCA Inventory. The California Proposition 65 Chemical(s) contained in this product are: **None**.
16.
OTHER INFORMATION
PREPARED BY .......: APPROVED BY .......: TITLE .............: APPROVAL DATE .....: SUPERCEDES DATE ...: RTN NUMBER ........: David Huelbig David Huelbig Safety Engineer December 19, 2003 New 00002918 (Official Copy)
********************************************************************** This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Ricoh Corporation. The data on this sheet are related only to the specific material designated herein. Ricoh Corporation assumes no legal responsibility for use or reliance upon these data. **********************************************************************