Presented by:
Binu Merrin Alex Tejasvini Dhuri Prity Maurya Nikita Powar
A device that allows the flow of current entirely. Mechanical devices that separates two bits of metal(contacts). When the metal doesnt touch, current doesnt flow. When the metal touches it is called a closed circuit. When the metal doesnt touch, is called an open circuit. (closed=ON, open=OFF)
But when it hits the contact, it debounces in the air Breaks the contact for a few milliseconds
In high speed digital logic applications we must consider another aspect of switch operation, the time dimension.
COM
B
Sr. no. 1. 2. 3. 4. 5.
Quantity 2 2 1 1 1
The circuit uses different components such as cross coupled 7400 gates, resistors and 5V battery and a single pole double throw switch to generate a single logic input. In this the pull up resistors are used to generate the logic circuit
Pin diagram of NAND gate
NAND
IC 7400
Q 10k 5V
Figure shows the debounce circuit. Two cross-coupled NAND gates form a simple Set-Reset (SR) latch.
To latch the value created by the input signal to the device and hold that value until some other signal changes it.
(set)
Switch Bounce happens when you close a mechanical switch A tendency of metal contacts to generate multiple signals.
Typical switches bounce for 10-20 ms, a very long time compared to the switching speeds of logic gates.
bounce .
5V 10k
Truth Table
S=0
Q
S
0 0 1 1
R
0 1 0 1
Q
1 0
Q
0 1
Not allowed
Q
10k 5V R=1
Latch
5V
SWITCH MOVES touches the other contact
Truth Table
10k
S=1
Q
S
0 0 1 Q 1
R
0 1 0 1
Q
1 0
Q
0 1
Not allowed
10k 5V
Latch
R=0
S=1
Q S 0 0 R 0 1 Q 1 Q 0 Not allowed
Q
10k 5V R=1
1
1
0
1
Latch