Authors: C. Besleaga, ECONET PROD, Bucharest, Romania R.M. Negriu, ECONET PROD, Bucharest, Romania I.C. Popescu, ECONET PROD, Bucharest, Romania S.G. Badea, ECONET PROD, Bucharest, Romania M. Stefanescu, ECONET PROD, Bucharest, Romania
Fig.4. Defections and wear of the elements of the excavator chain: a- zones of fracture; b- defective casting; c- wear of scraper
2. Introduction
Because of the factors that lead to the wear and the deterioration of the crushed stone degradation occurs by contamination and clogging of the stone prism, with the reduction of elasticity and permeability, with the formation of very hard objects, similar to the hardness of the stone (Fig. 1).
Fig.1. The clogging of the stone prism very hard bodies To restore the qualities of elasticity and permeability of the crushed stone prism, in terms of efficiency and technical-economic efficiency, re-using the corresponding crushed stone from the railway, technological mechanized operations of excavation of the crushed stone, cleaning, sorting, selection and waste elimination are performed. These technological mechanized operations are realized by the ballast cleaning machine, one example being MCB-450 (Fig. 2).
Fig.6. The tension state in two extreme cases from the analyzed cases
Fig.2. Ballast cleaning machine type MCB-450 and the excavation subassembly: 1 excavator chain; 2 - the chain wheel drive; 3 - guide / chute climb chain; 4 guide / chute descending chain; 5 cross piece; 6 - rotation (training) direction of the chain; 7-work movement; 9- screen; 10 rail; 11 clean crushed stone; 12 sand and gravel substrate; 13 - ground (soil); 14 clogged crushed stone Fig.7. Scraper corner made from composite material with WC and gradient of material: hardness measurements points; a and b zones with different properties; X- checked zone.
Fig.3. Spare parts of chain excavator: 1- joint bolt; 2- connecting chain link; 3scraper; 4- safety bolt of scraper; 5- left scraper shovel; 6- right scraper shovel; 7safety part; 8- safety bolt (screw) of joint bolt; 9- nut; 10-washer
5.Conclusions
Through our experimental research we identified the parts of the chain excavator type MCB-450 which are stressed at intensive wear. In the case of scrapers type MCB-450 we propose an improving through using of PM technology to decrease the wear. From analyzing the results obtained through the finite element method results: the equivalent tensions state from the elements of the chain do not exceed the allowable values of the equivalent tensions except locally, in the contact regions between the elements and the stones from the crushed stone prism; it is possible that the breakage of the elements may occur for stress at lower equivalent tensions that the maximum allowed, if there are material defects of relative critical dimensions at the local level tensions [10]; the maximum equivalent tension values from the contact region between the crushed stone prism and the elements of the chain explain the phenomenon of wear by cutting off small pieces of metal from that element. The analysis and the simulations performed using the finite element method lead to the finding of solutions for increasing the life spam of the excavator chain. The manufacturing of the scraper through methods specific to powder metallurgy and the shape optimization have been tested and represent a solution that must be generalized mainly because of the economical advantages obtained. The manufacturing of scraper shovels with a gradient of mechanical and physical characteristics of the material is in the experimental phase. The optimal technological solution will be validated through a big enough number of experiments, for a convincing economical analysis.