Voltage
Current
Power
Resistance
Power
Resistance
Attenuation
Voltage
True
False
Power
Wave Forms
Amplification
Amplitude
True
False
Loop Signaling
Amplification
Connecting
PBX
True
False
Direct Current
Wave Forms
Alternating Current
ARC-B-ACTS
Dual Connection
Dialing Control
Direct Current
DEOS Connectors
True
False
ESD
DC
AC
Hz
Electrostatic Discharge
Loop Signaling
Alternating Current
Telephony Networks
Loop Signaling
Operator Console
Serial Device Server
Model
onis
15)On-hook
________ describes when the phone
hook
___
the ______ and the loop is open.
16) TheOff-hook
________ describes when the phone
isoff____ thehook
_________ (picked up) and the
loop is closed allowing electricity to make
it back to the switchboard.
b)
c)
d)
Direct Current
Alternating Current
Amplification
Frequency
Positive, Negative, 60
Plus, Minus, 65
Plus, Minus 60
Positive, Negative, 65
True
False
Central Office
Switching Office
Public Switched
Branch Exchange
True
False
True
False
Service
Block
Joint
22X 29X
Marine Corps
32X 39X
Air Force
42X 49X
Army
52X 69X
Navy
72X
Spare
27) Analog
________ and Digital
__________ signaling are the
two types of methods that will be use.
Analog
28) __________
Signals are continuous
electrical signals that vary in time.
29) __________
Signals are non-continuous,
Digital
meaning they change in individual steps.
b)
c)
d)
e)
f)
True
False
Digital Telephones
Analog Telephones
Plain Old Telephones System
Network Telephones
Telephone Characteristics
Time Division Multiplexing
Digital Telephones
Network Telephones
POTS
Network Telephones
Analog Telephones
Dial Tone
POTS
38) A basic house phone is considered
a _______
Dual Tone Multi-Frequency
11
phone_________________________(DTMF),
RJ-___
connectors and Common Battery
Signaling/CBS) are the most common POTS
characteristics of a ______ phone.
True
False
Dial Tone
Phone Number
VX-900
E & M Signaling
Ring Tone
Framing
Transmit
Dual Tone Multi-Frequency
44)Encoding
________ is the process of coding the
256 ____
quantizing intervals assigned to the PAM
samples into8-bit
______ binary words.
45) The most common PCM method is to
sample a voice conversation
times
8,000 at _____
second
per ______.
Pulse Code Modulation
True
False
Internet
Protocol Address
50) The
____________________
is usually a
numerical label assigned to each device.
51) The
___________
Subnet
Mask defines the range of the IP
addresses that can be used within a
network.
52) A default gateway is a device (router) on
the network that has the ability to access or
send data packets to another page.
a)
b)
True
False
53) A codec
______ encodes a data stream or signal
for transmission, storage or encryption, or
decodes it for playback or editing.
54)Which three symbols are used in wire
diagrams?
a)
b)
c)
d)
e)
Switch Symbol
Codec Symbol
VX-900 Symbol
Telephone Symbol
Updating Symbol
55) Tags
______ are used to eliminate confusion
when tracing lines from a switchboard or
distribution devices to a phone.
56) At a minimum a tag should have the
following information written on both
sides with a grease pencil/china
marker;
Phone
#
_______, _________,
____________,
Subscriber
Type of Phone
Port ID # _______.
57) TheCAT-3
_____ cables are the most familiar
cables used with commercial telephone
systems also known as the phone cord.
True
False
True
False