in Materials
Creep
It is a time- dependent deformation
under a certain applied load.
Generally occurs at high
temperature (thermal creep), but can
also happen at room temperature in
certain materials (e.g. lead or glass).
As a result, the material undergoes
a time dependent increase in length,
which could be dangerous while in
service.
Creep Stages
Characteristics of Creep
Creep in service is usually affected by
changing conditions of loading and
temperature
The number of possible stresstemperature-time combinations is
infinite.
The creep mechanisms is often
different between metals, plastics,
rubber, concrete.
Creep Test
Measures dimensional changes
accurately at constant high temperature
and constant load or stress.
Useful for modeling long term
applications.
Provides prediction of life expectancy
before service. This is important for
example turbine blades.
Creep Test
Measures strain vs. time at constant
T and Load .
Relatively low loads and creep rate
Long duration 2000 to 10,000 hours.
Not always fracture.
Strain typically less than 0.5%.
Creep Test
Creep Parameters
To predict the stress and time for
long lives on the basis of much
shorter data.
Creep data is usually not available
beyond lives of more than 30000 hrs.
Larson Miller Parameter and other
material specific models are used.
problem
The chief engineer needs to know the permissible
stress that can be applied to the S-590 alloy for a
life of 20 years at 500C. with c=17
LMP= T(C+ log tr)
Imperfections in Solids
Point defects (zero-D)
Line defects (1-D) or
Dislocations,
Interfacial defects (2- D)
and Bulk or Volume defects
(3-D).
Point defects
Line defects
A dislocation is the defect
responsible for the
phenomenon of slip, by which
most metals deform
plastically.
Dislocations occur in high
densities (108-1010 m-2), and
are directly connected to
SCREW Dislocation
EDGE Dislocation
EDGE Dislocation
It is also called as Taylor-Orowan dislocation
Movement of Edge
Dislocation
Movement of Edge
Dislocation
Creep Mechanisms
If the vacancies move through the crystal lattice,
the behavior is called NabarroHerring creep
(Nabarro-Herring creep)
- Creep rate decreases as grain size increases
Grain Boundary Diffusion (Coble creep)
if the vacancies instead move along grain
boundaries, the behavior is termed Coble creep
Dislocation climb/ glide creep
- Controlled by movement of dislocations,
strong dependence on applied stress.
,Desired
service life
Problem
Consider a component
made of alloy S-590 is
subjected to a stress of
200MPa at a temperature
of 600C.
(a) Using Table above to
calculate the rupture
life for PLM.
(b) If the desired service
life is 1.5 years, what
are the safety factors
in life and in stress?