Weatherization
& Conservation
Yes we can!
Francis Rodrigue
Maine Certified Energy Auditor & Weatherization Tech.
Certified Home Inspector
Leasing Agent (homes & Apartments )
Realtor
2
Insulation Zone Map
Blue, Zone # 6 , Hard to Heat Zone
3
House Thermal View
Blue is cold, Red is hot (Winter Photo)
4
Air Conditioner Left in Window
5
Seal the Air Conditioner
6
HOUSE AS A SYSTEM
Buildings are systemsPeriod.
Everything in a building has the
potential to interact with everything
else.
The tighter a building is, the stronger
the interaction will be.
Codes that control trades practices
were, for the most part, written when
this potential was essentially
insignificant.
YOU need to understand your house, a
House as a System Science! 7
.
HOUSE AS A SYSTEM
8
*Questions well (try to) answer !
Why weatherize?
What is weatherization?
What is the owners role?
How are specific air sealing and
insulation done?
How do I know if its done right?
9
More Thermal Images
Useful in finding hot spots or heat loss
10
Weatherization goals
Create Safe Indoor Environment
Extend Dwelling Life
Increase Comfort
Save Money/Energy
11
*CONSERVATION
Conservation is the low
hanging fruit and easy to do
Every dollar you save
prevents $3 in building
expensive new power plants
12
Electric Power Generation
What can we do?
13
Home Electrical Usage
14
Light Bulbs
Which one uses more power?
15
Light Bulbs
Now, which one uses more power?
16
Energy Star Appliances
Save on power and water!
17
POWER STRIPS
When not in use, cut it loose!
18
Wrapped Hot Water Tank
Flow check and timer
19
Other Energy Savers
Low hanging fruit
20
* INDOOR AIR QUALITY
Indoor air can be more
polluted than outside
air !
Name examples of pollution!
21
INDOOR POLUTANTS
Asbestos
Biological Pollutants
Carbon Monoxide
Formaldehyde/Pressed Wood Products
Household Cleaning and Maintenance, Personal Care, or Hobbies
Lead Paint
Mercury ?
Nitrogen Dioxide
Pesticides
Radon
Resparable Particles
Secondhand Smoke/Environmental Tobacco Smoke
Stoves, Heaters, Fireplaces, and Chimneys
Un-vented combustion appliances
VOC Volatile Organic Compounds
22
Moisture Pollution
23
IAQ venting requirements
Moisture is considered a pollutant in buildings
Install carbon monoxide detectors on all
levels
All combustion appliances must vent properly.
Driers must be vented to the exterior.
Garages must be cut off from the living space.
All existing bathroom & kitchen fans must be
vented to the exterior.
24
Catch that lint !
25
Off Gassing
Everything in the building off gasses
Carpets and upholstery
Paint and stains
Wood and vinyl flooring
Cleaning chemicals
Items stored in the garage & basement
Never store flammables inside !!!
26
Paints And Other Compounds
27
Weaker draft heating appliances:
Houses have: If your house is very tight, the
house vents could cause back-
drafting of exhaust gases and
a potential carbon monoxide
hazard. (CO2 detectors a must)
28
* BUILDING
CONSTRUCTION STYLES
31
Balloon
framing
32
Platform Framing
33
*SINGLE FAMILY HOME
WEATHERIZATION
Air seal (everything) 1st
Insulate attic
Insulate walls
Insulate basements
35
HOUSE AS A SYSTEM
in the Attic and basement
37
Thermal Envelope
38
Building Thermal Envelope
Consists of:
Air barrier (pressure barrier)
- Vapor (re-tarder) barrier
- Insulation barrier.
All at the same surface & in contact with each other.
Should be as simple as possible:
Least area of heat exposed to the cold.
Smallest volume of heated space.
Fewest & least difficult joints.
Weigh your options: i.e. build hatch at top of attic
stair as opposed to addressing stairwell walls &
stair treads.
39
Where to Insulate
How Much?
40
Why in contact?
12 Air-tight plaster
insulation ceiling
No
Porous
insulation
By convection (stack - warm block tile
air rising), room air freely
moves through the block tile ceiling
& insulation, warming the This configuration
area between the ceilings to slows heat
the same temperature as the
room below.then
transfer, but,
The heat
given enough
radiates/conducts
time, the same
through the un-insulated
amount of heat 41
is
ceiling to the attic.
*AIR LEAKAGE
REDUCTION
Intended to:
Stop moisture (99% of moisture air carried)
The average air change of a house (1 hour)
Allows insulation particularly fiberglass to function
as rated
Makes home less drafty
Saves energy
Very detail specific (very nook & cranny)
Most easily done during construction
Insulation alone will not reduce air leakage!
42
Air Sealed Windows
43
In the real world
(2) Wind
47
Three Atrium Doors
R=2, Hugh heat loss! What can we do?
48
Where to look !
49
Air Sealing Task
50
Attic
Note heavy mold
& water
Attic super
connected to living &
very wet crawl space
below. Soaked insulation
51
More Air Sealing
Why:
Control unwanted air movement
Save energy
Reduce future structural damage
When & Where:
Always! At heating envelope.
How:
Non-degrading products sealed in place
What surface:
Crawl: at perimeter & ground
Attic: at top of heated space
Both: in contact with the insulation 52
Breaker Box/ Wire Seal
53
Foam Seal Wires & Plumbing
54
Fresh Air Vent to Boiler
55
Recess Light Above Shower
56
* INSULATION
Fiberglass Batts
Cellulose Blown-in
Foam board or sprayed
Denim batts
Asbestos, rock wool,
vermiculite
57
R value per inch
Cellulose: 3.0 (dense-pack) to 2.5 (loose fill)
Fiberglass: 3.5/in. (regular density)
Foam boards (i.e. Styrofoam): 5/in.
Two part foam: 5 to 7/in
Foam board with reflective coating: 7/in.
Glass: R= 1 per layer
Concrete: R=1 per 8 thickness
58
Fiberglass Insulation Samples
59
New Green Insulation
Recycled Denim
60
Why do we insulate? Does it work?
Save energy Yes
Remove moisture No
Prevent condensation No
Dries up mold No
Prevent rot No
Extend shingle life Probably
Satisfy code officers Usually
61
Other insulations
62
Two Part Spray Foam
63
Insulation requirements
Completely air-seal attics before installing any
insulation.
Fill all closed cavities (walls & floored, attics).
Insulate open attics to R-38/49.
Cellulose: dense pack all closed cavities to
3.5 lb/cu ft.
Dam all insulation away from chimneys &
recessed lights.
Dam the attic entry to prevent insulation from
falling into the living space. 64
Either ascertain that buried Knob &Tube
electrical circuits are not - & can not be
overloaded, eliminate them or dam insulation away
from them.
Tag any buried electrical junction boxes.
Never know what youll find.
65
Installing fiberglass
Friction fit batts are preferable to the foil or
paper backed product.
Slightly higher R per inch
Faster installation
Backing contributes nothing
Must be in contact with winter-warm surface.
Poor choice for open floor attics:
Expensive per R
Allows wind-washing
Takes longer to blow same area.
66
Todays terms* !
1. Air intrusion =
2. Infiltration =
3. Ex-filtration =
4. Wind-washing =
69
Fiberglass vs. cellulose
Fiberglass does not absorb water, cellulose
does.
Fiberglass is lighter than cellulose.
Fiberglass does not react with metal, cellulose
can. (galvanic reaction)
Fiberglass allows air movement, cellulose
(properly installed) prevents it.
Fiberglass may be carcinogenic, cellulose isnt.
Fiberglass cant be dense-packed, cellulose can.
70
*HARD TO REACH AREAS
Band Joist between floors
Knee walls
Chimney and utility chases
Built-ins and pocket doors
Fuel tank fill pipes
71
Garage Attic/Living Space Below
72
Pay attention to details !
73
Upper story band joist (platform)
Same exposure/area as in basement.
Greater T (temp. diff) so greater heat loss.
Harder to access (in retrofit).
Air seal & insulate by:
Removing trim (inside or outside).
Unzipping vinyl siding.
Blowing cellulose or foam into cavity.
74
Band Joist
75
Typical gable end details Eve side similar
Band Joist (bag Trick)
76
Knee walls
& side
attics
79
Another consideration
82
Plumbing To Bath Tub
83
Fuel Tank Fill Pipes
84
* HOUSE ATTICS
Attic Hatches
86
Roof Construction Terms
87
Attic insulation
Cellulose is preferred;
Reduces looping & wind washing
Recycled green product (ground up newspaper)
Generally less expensive per effective R
Requires careful preparation:
AIRSEAL EVERYTHING!
Dam insulation from chimney & recessed lights
Check K&T for overloads & isolate or eliminate
Dam attic hatch
Prevents Wind washing & looping
88
Looping
House Attic
91
Drop Down Attic Hatch, Sealed
93
Why do we vent attics? Does it work?
Remove moisture Rarely
Prevent condensation No
Extend shingle life No
Save energy No
Prevent Ice Dams Sometimes
Satisfy code officers Usually
Is a hot roof better Sometimes
94
Hot Roof or Hot Ceiling
Air sealed and Insulated
95
Attic ventilation
Very arbitrary; based on a 3 house
study done in the Midwest prior to
WW II.
Does not cool roof deck.
Roof temp more dependent on
shingle color & sun exposure than
ventilation.
See: www.buildingscience.com
. 96
Ridge vent air source ?
1 x 4 matched 97
Ceilings are no different !
99
Attics revisited (One last time!)
The vast majority of air moving through Maine houses
during the heating season is driven by stack effect.
This can account for as much as 60% of heat loss!!
Insulating an attic without air-sealing it will not reduce
the volume of air moved into the attic by stack effect.
Insulating the attic will lower the attic temperature
causing condensation on surfaces which previously
remained above the dew point.
Adding attic venting will most likely cause even more
condensation in the attic as the relief at the top will
pull harder on the house, moving more house air up.
The ONLY reliable fix is air sealing and
eliminating the source of moisture 100
*BASEMENT FOUNDATIONS
Rubble Stone and granite
Crawl Spaces (post & pier)
Brick and blocks
Pressure treated
Poured concrete
New- Foam blocks
101
Pick your house site wisely
Why are Basements in Maine wet ?
102
Ground Pitches Towards
the Foundation
103
Why Is My Basement Wet?
104
Rubble Stone and Granite
Common From 1800 to 1920
105
Post and Pier
Crawl Space
106
Brick and blocks
107
New Construction
Complete foundation insulation . . . $5400.00
24 x 48 (1152sf)
Estimated energy savings... $450.00/year
Estimated dehumidification saving $300.00/year
Professional mold remediation... $2000.00
Dry, warm, healthy basement... priceless
108
Pressure treated wood foundation
Not Common
109
New- Foam blocks
110
Basement box sill (band joist)
Insulation the basement (as important as attic)
Sill plate must be sealed to the foundation:
Exterior or interior ok do whichever is easiest.
One or two part foam.
Silicone caulk.
Caulk or foam all penetrations.
Insulate sill cavities with 2 foam board. Air-
seal edges to framing. (preferred method)
6 Fiberglass batts with backing caulked or
foamed to framing is acceptable..
111
Septic Drain Pipe
112
The ultimate crawl retrofit !
113
*MOBILE HOMES
Have their own unique
challenges.
114
Mobile home weatherization
Long fiber (Insulsafe III) fiberglass preferred:
Lighter per cubic foot.
Wont absorb water.
No galvanic reaction.
Duct sealing a priority:
Ducts are outside the air barrier.
Typically either poorly installed or damaged in transit.
All joints important.
Eliminate factory floor return systems:
Plug all return floor register openings.
Undercut interior doors for free return air flow.
Install louver door on furnace closet. 115
Is The Leak Vent or Sky Light
116
Manufactured housing
119
Mobile Home Blown-in fiberglass in
the attic.
Weatherization
120
*ENERGY AUDIT TOOLS
Blower Door
Infrared Camera
Smoke stick
Vent and Duct Testers
121
* Why do an Energy Audit ?
Extend building
life:
The same conditions
that lower IAQ can
reduce building
durability.
123
Manometer
Blower Door Computer
124
Infrared (IR)
Sees surface temperature only
Very powerful when used with the blower door
IR alone followed by IR with BD.
First IR establishes normal cond-
ition air leakage pattern, second
IR with blower door shows what
happens under artificial air pressure.
Interpretation is key
Does not see thru walls
125
Smoke stick
Makes smoke to help find
drafts around walls
http://metermall.com/product
%20pages/Smoke/Smoke%20Emitters.htm
126
Vent and Duct Testers
127
Infrared Gun
Finds temperature at one location.
128
Think and be
safe !
129
REVIEW
HOUSE AS A SYSTEM 7
CONSERVATION 12
INDOOR AIR QUALITY 21
BUILDING CONSTRUCTION STYLES 29
SINGLE FAMILY HOME WEATHERIZATION 34
AIR LEAKAGE REDUCTION 40
INSULATION 54
HARD TO REACH AREAS 68
HOUSE ATTICS 82
BASEMENT FOUNDATIONS 97
MOBILE HOMES 110
ENERGY AUDIT TOOLS 117
131
ENERGY AUDIT CLASS
Next Class
Wednesday : February 25th 2009
Same time, same location
Cost $ 7.00
132
QUESTIONS
133