0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
6 tayangan11 halaman
This document discusses an experiment on an op-amp inverting circuit. It provides an overview of how an op-amp works by comparing the two input voltages and outputting a voltage based on their difference. It then lists the names of three students and describes the equipment used, including an oscilloscope, function generator, and power supply. The procedure involves setting up the circuit with a 10V power supply, 1kHz 1Vpp signal generator input, and observing the output voltage and phase difference.
This document discusses an experiment on an op-amp inverting circuit. It provides an overview of how an op-amp works by comparing the two input voltages and outputting a voltage based on their difference. It then lists the names of three students and describes the equipment used, including an oscilloscope, function generator, and power supply. The procedure involves setting up the circuit with a 10V power supply, 1kHz 1Vpp signal generator input, and observing the output voltage and phase difference.
This document discusses an experiment on an op-amp inverting circuit. It provides an overview of how an op-amp works by comparing the two input voltages and outputting a voltage based on their difference. It then lists the names of three students and describes the equipment used, including an oscilloscope, function generator, and power supply. The procedure involves setting up the circuit with a 10V power supply, 1kHz 1Vpp signal generator input, and observing the output voltage and phase difference.
2. Fadhilatus S. (09) 3. M.Rezza Syahrizal (12) Op Amp Inverting The principle of working an operational amplifier (Op-Amp) is comparing the values of the two inputs (inverting input and non- inverting input), if both inputs are equal then the Op-amp output is 0 and if there are differences in the input values both the Op- amp output will give the output voltage. Operational amplifier (Op-Amp) is made from a differential amplifier with 2 inputs. Ѳ= ∆t x F x360° Equipment and Material Practicum module Connecting cable Oscillosacope Power supply Function generator Banana to Banana BNC to Banana Trial Procedure 1)Measure the power supply with a voltage of 10 V. 2)Setting generator functions with a frequency of 1 khz and amplitude of 1 Vpp. 3)Observe Vout and phase difference. Thank you for your attention