Anda di halaman 1dari 21

Computer System and

Network Configurations
Smooth Setup and Making Network Connection
Smooth Setup
• One key advantage of a peer-to-peer network is that it’s easy
to setup. With the simplest sort of peer-to-peer network, you
just use the built-in networking that comes with your
operating system (Windows 98, Windows XP, Windows 7,
Windows 8 and so on) and you have very little software to set
up – even less if you have computers that have the operating
system preinstalled, as most computers do these days.
To create a peer network, you must
have the following components:
• A network interface or Local Area Network (LAN) adapter
for each computer. The same manufacturer and model of
network card is preferred.
• Cabling that is supported by the network cards.
• Windows XP or 7 drivers for the network cards.
• A common network protocol.
• A unique computer name for each computer.
Making Cables
Tools and Procedures
Tools and Materials Needed

UTP Cable RJ45

Crimping Cutter
tool
Steps
1. Remove the outmost vinyl shield for 12mm at one end of the
cable (we call this side A-side).
2. Arrange the metal wires in parallel (refer the each section's wire
arrangement table). Don't remove the shield of each metal line.
3. Insert the metal wires into RJ45 connector on keeping the metal
wire arrangement.
4. Set the RJ45 connector (with the cable) on the pliers, and
squeeze it tightly.
5. Make the other side of the cable (we call this side B-side) in the
same way.
6. After you made it, you don't need to take care of the direction of
the cable. (Any cable in this page is directionless --- that means you
can set either end of the cable to either device.)
1. Remove the outmost vinyl shield for 12mm at one
end of the cable (we call this side A-side).
2. Arrange the metal
wires in parallel
(refer the each
section's wire
arrangement table).
Don't remove the 1 2 3 4 5 6 7 8
shield of each metal
line.
Color Pin (T568B)

White/Orange 1

Orange 2

White/Green 3

Blue 4

White/Blue 5

Green 6

White/Brown 7

Brown 8
3. Insert the metal wires into RJ45 connector
on keeping the metal wire arrangement.
4. Set the RJ45 connector (with the cable) on the pliers, and
squeeze it tightly.
5. Make the other side of the cable (we call this side B-side) in the
same way.
6. After you made it, you don't need to take care of the direction
of the cable. (Any cable in this page is directionless --- that means
you can set either end of the cable to either device.)
Title and Content Layout with Chart
6

0
Category 1 Category 2 Category 3 Category 4
Series 1 Series 2 Series 3
Two Content Layout with Table
• First bullet point here Class Group 1 Group 2
• Second bullet point here Class 1 82 95
• Third bullet point here Class 2 76 88

Class 3 84 90
Title and Content Layout with
SmartArt

Step 1 Title Step 2 Title Step 3 Title Step 4 Title


Task description Task description Task description Task description

Task description Task description Task description Task description

Task description Task description

Task description
Add a Slide Title - 1
Add a Slide Title - 2
Add a Slide Title - 3
Add a Slide
Title - 4
Add a Slide
Title - 5

Anda mungkin juga menyukai