4. If the tool is upright, aim it at point f with zero set on the device, then measure the distance
from IP to F ...
5. After that, measure the distance from F to BC ...
6. refer the device from the IP point to bc with the zero set.
7. Next point the IP point to the EC point, with a set angle of 180 degrees, with a distance ...
8. If the distance F, BC, EC is correct with the calculated data, move the tool to point F
9. Set the tool so that the tool is upright, by adjusting the nivo tube and aligning the tool with
nails in the peg.
10. If the tool is upright, aim for a shot by aiming the tool at point F with the tool set to zero
11. After that point the tool to the point BC with a zero set with a distance of 1.21 m, give a
mark on the point with stakes that have been given paper as a sign.
12. Then if the BC point is correct then move the style to the BC point and set the tool so that it
is upright with the midpoint of the tool just below the midpoint of the nail.
13. If the tool is upright, then start shooting again.
14. refer the tool from point BC to P1 at an angle ... with the distance from point BC to P1 1.23
m, mark the point with the paper marked as a mark.
15. refer the device from BC to point P2 at an angle ... with the distance from point p1 to p2 3 m,
mark the point with the paper marked as a mark.
16. refer the tool from point BC to p3 at an angle ... with the distance from point p2 to p3 3 m,
mark the point with the paper marked as a mark.
17. Shoot the tool from point BC F to point MC with an angle ... with the distance from point p3
to MC that is 0.802 m, give a mark on the point with stakes that have been given paper as a sign.
18. refer the device from point BC to point P4 at an angle ... With the distance from point p3 to
p4 which is 3 m, mark the point with stakes that have been given paper as a mark.
19. refer the tool from point BC to point p5 at an angle ... with the distance from point p4 to
point p5 which is 3 m, mark the point with the paper marked as a sign.
20. refer the tool from point BC to point EC with an angle, .. then measure the wine from p5 to
point ec whether it matches the data that has been calculated, then measure the distance from
point f to point EC if it matches the data that has been calculated, then the measurements made
have been successful.