MOTOR AC
Relationship between load, speed and torque (torque)
The picture below shows a graph of the relationship between torque - speed with current at
3 phase induction motor:
• The motor starts to turn on, there is a high start current but the torque is low.
• When the motor reaches 80% of full speed, the torque reaches its highest point and
Current began to decline.
• When the motor has reached full speed, or synchronous speed, torque and current
the stator drops to zero.
Hubungan antara beban, kecepatan dan torsi (torque)
Gambar di bawah ini menunjukkan grafik hubungan antara torque - kecepatan dengan arus
pada motor induksi 3 phase:
• Motor mulai menyala ternyata terdapat arus start yang tinggi akan tetapi torque-nya
rendah.
• Saat motor mencapai 80% dari kecepatan penuh, torque-nya mencapai titik tertinggi
dan arusnya mulai menurun.
• Pada saat motor sudah mencapai kecepatan penuh, atau kecepatan sinkron, arus
torque dan stator turun ke nol.
.
NAME PLATE OF INDUCTION MOTOR
PLAT NAMA MOTOR INDUKSI
First Number: Protection against solid objects. Protected from the entry of solid objects
0 = There is no special protection. Like cables without insulation in the panel.
1 = greater than 50mm
2 = greater than 12 mm. For example touched hammer fingers etc.
3 = Greater than 2.5 mm. For example wire or keys etc.
4 = greater than 1 mm. For example fine wire or small screwdriver etc.
5 = Dusty environment.
6 = Dustproof at all.
Angka Pertama : Perlindungan terhadap benda padat. Terlindung daru masuknya benda
padat
0 = Tidak ada perlindungan khusus. Seperti kabel tanpa isolasi didalam panel.
1 = Lebih besar dari 50mm
2 = Lebih besar dari 12 mm. Misalnya tersentuh jari palu dll.
3 = Lebih besar dari 2.5 mm. Misalnya kawat atau kunci-kunci dll.
4 = Lebih besar dari 1 mm. Misalnya kawat halus atau obeng kecil dll
5 = Lingkungan berdebu.
6 = Sama sekali kedap debu
So IP 54 means it's safe to use in dusty environments and the possibility of frequent water
spray.
Jadi IP 54 berarti aman dipakai di lingkungan berdebu dan kemungkinan sering kena
semprotan air.
In the figure above this is the name plate on a motor, with IP 55.
This means that the motor, is resistant to dust and water spray
Pada Gambar diatas ini adalah name plate pada sebuah Motor, dengan IP 55.
Berarti Motor tesebut, tahan terhadap debu dan semprotan air.
The formula calculates synchronous speed, if the known frequency and number of caps on
the AC motor.
Rumus menghitung kecepatan sinkron, jika yang diketahui frekuensi dan jumlah kutup pada
motor AC.
Contoh : hitung kecepatan putar motor 4 poles/kutup jika motor dioperasikan dengan
frekuensi 50 hz.
ns = (120. F)/ P = (120 . 50)/ 4 = 1500 rpm.
menghitung slip pada motor:
Contoh : hitung slip motor jika diketahui kecepatan motor 1420 rpm. Dengan kecepatan
sinkron yang sama dengan hasil diatas.
% slip = ((ns - n)/ ns) x 100 = ((1500 - 1420)/ 1500)x 100 = 5 %
ns = Kecepatan sinkron medan stator
n = Kecepatan rotor
Contoh. Hitung besarnya arus(ampere) motor dengan daya 1 kw dan tegangan 220V
dengan faktor daya 0,88.
I = P / V. Cos φ.....P = 1 kw = 1000 watt
I = 1000/(220 . 0,88) = 5 Ampere.
Menghitung daya motor 3 phasa ketika diketahui arus, tegangan, dan faktor daya.
Contoh.
Hitung daya motor induksi 3 phasa yang memiliki arus 9,5 A dengan tegangan 380V dan
faktor daya/ cos φ 0,88. P = √3 .V. I . cos φ = 1,73 . 380 . 9,5 .0,88 = 5.495 watt atau
dibulatkan jadi 5,5 KW.
Contoh. Dengan daya input motor 5 KW dan daya output 4,5 KW. Hitung efisiensi daya
pada motor tersebut.
ᶯ = (Pout / P)x 100% = (4500/5000)x 100% = 90 %.
Menghitung torsi motor jika diketahui daya motor dan kecepatan motor.
Hubungan antara horse power, torsi dan kecepatan.
Contoh. Hitung berapa torsi motor 10 HP.
Dengan kecepatan 1500 rpm.
T = (5250 . HP)/n = (5250 . 10)/ 1500 = 35 lb ft = 45,6 Nm
-----------------------------------------oooo0000oooo--------------------------------------