Tindakan: Tutup terminal baterai atau meleleh. ON dan ganti sekring jika terbakar.
Tindakan: Perbaiki pagar yang rusak
aliran udara
dengan bahan isolator yang kuat aliran udara di ruang baterai
dan selalu kunci rumah pembangkit.
(misal: kotak plastik, kotak kayu). Cek kondisi MCB, sekring dan Cek apakah semua MCB,
SPD pada combiner box sekring, dan SPD pada panel
Cek apakah setiap modul surya Cek apakah lampu jalan Cek semua sistem pembumian
Tindakan: Pastikan semua MCB distribusi AC masih dalam Apakah ada bukaan Tidak
dalam keadaan baik
Tindakan: Putuskan dari rangkaian
Cek apakah ada kebocoran
elektrolit pada baterai
dalam posisi ON, sekring berfungsi keadaan baik
beroperasi dan tidak terhalang
pohon
terpasang dengan baik
Tindakan: Pastikan semua sistem ventilasi udara yang
Apakah ada sumber Ya
Tindakan: Laporkan kebocoran pada
dengan baik dan indikator SPD Tindakan: Pastikan MCB dalam
pembumian (modul surya struktur, panas lain di ruangan Ide: jika dinding ruang baterai terkena
dan ganti modul surya yang rusak. berwarna hijau. Ganti sekring dan posisi ON, ganti sekring jika sudah
Tindakan: Tebang pohon atau dahan terhalang atau
Ganti pada saat tidak ada cahaya baterai. Hati-hati dengan bahan SPD jika diperlukan. Laporkan jika terbakar, dan ganti SPD jika
yang berpotensi menutupi cahaya tiang penangkal petir, SPD, rumah itu? Ya banyak cahaya matahari, pertimbangkan
matahari. kimia yang korosif! MCB selalu kembali OFF. lampu atau merusak jaringan pembangkit) saling terhubung. terhambat?
berwarna merah.
membuat bayangan menggunakan tiang
Cek tidak ada lubang pada Cek apakah semua kabel
Tidak bambu yang bersandar dengan longgar
6 bulanan
Konsep dan desain: Robert Schultz, Amalia Suryani, Bagus Ramadhani | ENDEV Indonesia © Agustus 2017
Minta Bantuan
Communication cable
Photovoltaic array
DC voltage
Turn circuit breaker Circuit breaker switch 1. Check for short circuited wiring on
Low voltage AC
Pyranometer switch ON switched OFF again? distribution cables to the customers;
Medium voltage AC Yes and
Power flow when charging
Combiner box
No
Power flow when discharging
2. Check overload at customers and
* Optional Check and fix electricity in one house
Yes try reducing load
1. Unplug all devices and switch circuit breaker ON
2. Check voltage at main connection Is circuit breaker switch
to households at power Are battery and
3. Check voltage at all sockets Are there loose or Fix or reconnect the
DC panel house ON? inverters operating
4. Plug on the devices (one by one)
well? broken cables? cables
5. Check circuit breaker; if trip then the device is
Grid pole and shorted or the load is too high for one customer
Yes Yes
Battery bank streetlights
6. Repeat from step 4 until broken devices known
No
Monitoring system or max load identified No
Check for RED light
Battery inverter Technician name: ___________________________________________
on battery inverter
Lightning Technician phone number: ___________________________________
mast
Customers 220 V
1) Before testing 2a) Good appliance 2b) Shorted appliance
Ask for Help
Solar charge All customers 1. Check for broken cable and
controller reconnect
REMEMBER! Check voltage (220 V) at all 2. Check for too many electricity
connections
1. Sunny days ensure that
the batteries are well
No electricity? households connected on the
same distribution branch
charged.
Action: Clean the surface of solar solar modules 1. Check all cables at PV system
modules with a brush or cloth. Only Action: Sweep and mop the power entrance to avoid the animal
entering the power house.
controller? The RED light on
2. Switch OFF all loads until
use water as a cleaning fluid.
Notes:
house regularly. Clean and trim the charge controller is
SPD: Surge Protection Device
plants under the solar module.
ON? battery is fully recovered
Check the battery room
Check shading on the solar MCB: Miniature Circuit Breaker
AC: Alternating Current temperature
modules Check whether the vents are Action: Make sure the ventilation is Note: “Low battery voltage” indicates
DC: Direct Current
Action: Remove tree branches or tightly closed and clean not blocked by dirt. If it remains hot, that battery is not sufficiently charged.
other objects that cause shadows. Action: Repair the perforated screen exhaust fans or additional canopies Fully charging the battery may take a few
Check whether the cable
and clean it regularly from dust. can be installed. Overheating of days.
connections in the combiner
box are safe, dry, and clean Checks whether the fence is in battery room?
Check if the battery terminals Action: Tighten the loose Check whether all MCBs or good condition (can be locked,
are protected by insulating fuses on the DC distribution
materials, tight and not rusty
connection and make sure that no
cable insulation is damaged. panel are still operating
not corroded, sturdy, and no slit
of livestock to enter)
Yes Remove obstruction Idea: use a mobile electric
Monthly
Action: Cover battery terminals with Replace the terminal if there is a Action: Make sure the MCB is ON Action: Fix the damaged fence and
to improve air flow fan to improve air flow in
strong insulators (e.g. plastic boxes, sign of burning or melting. and replace the fuse if it burnt. always lock the generating house.
wooden boxes). the battery room
Check MCB condition, fuse
Check whether each solar and SPD on combiner box Check that all MCBs, fuses, and Check whether the street lights Check all grounding systems are
Check if there is any electrolyte
module is in good shape
leak in the battery
Action: Make sure all MCBs are ON, SPD on the AC distribution
panel are still in good condition
operate and are not blocked by
the trees
installed properly
Are any air ventilation No Yes
Action: Disconnect from the circuit the fuse is working properly and the Action: Make sure all grounding Are there other heat
and replace the damaged solar Action: Report if there is a leak in SPD indicator is green. Replace fuses Action: Make sure MCB is ON, Action: Cut that trees or branches systems (solar module structures, openings blocked or Idea: if a battery room wall is
module. Replace when there is no the battery. Be careful with and SPD if needed. Report if MCB replace the fuse if it is burnt, and that have the potential to cover lightning rods, SPD, power house) sources in the room?
sunlight. corrosive chemicals! replace the SPD if it is red. sunlight or damage the network. are connected.
obstructed? Yes exposed to a lot of sun light,
always returns OFF.
consider shading it using bamboo
Check the temperature and No
6 monthly
Concept and design: Robert Schultz, Amalia Suryani, Bagus Ramadhani | ENDEV Indonesia © Agustus 2017
Ask for Help