Olga Cinza Soares Marques, 01147067, AKADEMI TEKNIK
RADIOGDIAGNOSTIK DAN RADIOTERAPI ( ATRO BALI), Uji Reproduksibilitas mA Pada Pesawat Sinar-X Merk Mis Mengunakan Dosimeter Saku Di Laboratorium Atro Bali, bertujuan untuk mengetahui hasil Uji Reproduksibilitas Ma Pada Pesawat Sinar-X Merk Mis Mengunakan Dosimeter Saku Di Laboratorium Atro Bali. Jenis penelitian ini memggunakan penelitian kuantitatif dengan pendekatan eksperiment. Uji Reproduksibilitas ini dilakukan pada pesawat Sinar-X Merk Mis Mengunakan Dosimeter Saku Di Laboratorium Atro Bali pada bulan Mei 2017. Jarak antara tabung Sinar-X ke alat ukur dosimeter diatur 100 cm. factor eksposi diatur pada 80 kV, dengan variasi nilai mA yaitu 80 mA, 100, 125, 160, 200, dan s 0,125, 0,100, 0,080, 0,063, 0,050 s. hasil pengukuran uji reproduksiblitas diperoleh 313±0,01, 211±0,005, 179 ±0,006 , 150±0,006, 121±0,01 . Jadi nilai perbedaan antara coefisisien of variance yang diperoleh dari penelitian lebih kecil dari nilai coefisisien of variance yang ditetapkan di AAPM. sesuai dengan keputusan yang telah di tetapkan oleh AAPM nilai coeficient of variance harus ≤ 0,05. semua menunjukan nilai coeficient of variance dibawah 0,05. Berarti dapat disimpulkan bahwa uji reproduksibilitas mA terhadap paparan radiasi yang dihasilkan oleh pesawat sinar-X MERK MIS masih dalam keadaan konsistensi. Kata kunci : Uji Reproduksibilitas mA, Pesawat Sinar-X,Dosimeter saku ABSTRAC Olga Cinza Soares Marques, 01147067, RADIOGDIAGNOSTIC AND RADIOTERAPY TECHNIQUES (ATRO BALI), mA Reproducibility Test On X-Ray Plane Mis Brand Using Pocket Dosimeter At Atro Laboratory Bali Aims to know the results of Test Reproducibility Ma On Aircraft X-ray Brands Using Pocket Dosimeter At Atro Laboratory Bali. This type of research uses quantitative research with experimental approach. Reproducibility test was conducted on the X-ray Brands Mis Mis Use of Pocket Dosimeter At Atro Laboratory Bali in May 2017. The distance between the X-ray tube to the dosimeter gauge is set to 100 cm. The exposure factor is set at 80 kV, with variations of mA values of 80 mA, 100, 125, 160, 200, and s 0.125, 0.100, 0.080, 0.063, 0.050 s. The results of reproducibility test measurements obtained 313 ± 0.01, 211 ± 0.005, 179 ± 0.006 , 150 ± 0.006 , 121 ± 0.01 . Thus the value of the difference between the coefficient of variance obtained from the study is smaller than the coeficient value of variance defined in AAPM. According to the decision set by the AAPM the coeficient of variance value shall be ≤ 0.05. All indicate the coeficient of variance under 0.05. It can be concluded that the mA reproducibility test on the radiation exposure produced by the MERK MIS X-ray plane is still in a state of consistency Keywords: Reproducibility test mA, X-ray plane, pocket dosimeter