Coatings are to be applied to the specimens in a manner that is consistent with that to be used in the actual intended structural application. The method of applying the coating and the surface preparation shall be given in the test report. The specimens are to be coated to an average thickness that is 2 mils greater than the maximum thickness to be used in the structure on both of the plate surfaces (the faying and outer surfaces). The thickness of the total coating and the primer, if used, shall be measured on the contact surface of the specimens. The thickness shall be measured in accordance with SSPC-PA2 (SSPC, 1993; SSPC, 1991). Two spot readings (six gage readings) shall be made for each contact surface. The overall average thickness from the three plates comprising a specimen is the average thickness for the specimen. This value shall be reported for each specimen. The average coating thickness of the creep specimens shall be calculated and reported. The time between application of the coating and specimen assembly shall be the same for all specimens within ±4 hours. The average time shall be calculated and reported.
Figure A-1. Compression slip test specimen.
Specification for Structural Joints Using High-Strength Bolts, August 1, 2014
RESEARCH COUNCIL ON STRUCTURAL CONNECTIONS Pelapisan harus diterapkan pada spesimen dengan cara yang konsisten dengan yang akan digunakan dalam aplikasi struktural yang dimaksudkan sebenarnya. Metode penerapan pelapisan dan persiapan permukaan harus diberikan dalam laporan uji. Spesimen harus dilapisi dengan ketebalan rata-rata 2 mil lebih besar dari ketebalan maksimum yang akan digunakan dalam struktur pada kedua permukaan pelat (permukaan faying dan permukaan luar). Ketebalan lapisan total dan primer, jika digunakan, harus diukur pada permukaan kontak spesimen. Ketebalan harus diukur sesuai dengan SSPC-PA2 (SSPC, 1993; SSPC, 1991). Dua pembacaan spot (enam pembacaan gage) harus dilakukan untuk setiap permukaan kontak. Ketebalan rata-rata keseluruhan dari tiga pelat yang terdiri dari spesimen adalah ketebalan rata-rata untuk spesimen. Nilai ini harus dilaporkan untuk setiap spesimen. Ketebalan lapisan rata-rata spesimen creep harus dihitung dan dilaporkan. Waktu antara penerapan lapisan dan rakitan spesimen harus sama untuk semua spesimen dalam waktu ± 4 jam. Waktu rata-rata harus dihitung dan dilaporkan.