ATMega
ATMega
ATMega16
1. Advanced RISC Architecture
130 Powerful Instructions – Most Single Clock Cycle Execution
32 x 8 General Purpose Fully Static Operation
Up to 16 MIPS Throughput at 16 MHz
On-chip 2-cycle Multiplier
2. Nonvolatile Program and Data Memories
8K Bytes of In-System Self-Programmable Flash
Optional Boot Code Section with Independent Lock Bits
512 Bytes EEPROM
512 Bytes Internal SRAM
Programming Lock for Software Security
3. Peripheral Features
Two 8-bit Timer/Counters with Separate Prescalers and Compare
Mode
Two 8-bit Timer/Counters with Separate Prescalers and Compare
Modes
One 16-bit Timer/Counter with Separate Prescaler, Compare
Mode, and Capture Mode
Real Time Counter with Separate Oscillator
Four PWM Channels
8-channel, 10-bit ADC
Byte-oriented Two-wire Serial Interface
Programmable Serial USART
4. Special Microcontroller Features
Power-on Reset and Programmable Brown-out Detection
Internal Calibrated RC Oscillator
External and Internal Interrupt Sources
Six Sleep Modes: Idle, ADC Noise Reduction, Power-save, Pow
down, Standby and Extended Standby
5. I/O and Package
32 Programmable I/O Lines
40-pin PDIP, 44-lead TQFP, 44-lead PLCC, and 44-pad MLF
6. Operating Voltages
2.7 - 5.5V for Atmega16L
4.5 - 5.5V for Atmega16
ATmega 32
1. Sistem processor 8 bit berbasis RISC dengan kecepatan maksimal 16 MHz.
2. Ukuran memory flash 8KB, SRAM sebesar 512 byte,
3. EEPROM sebesar 512 byte. ADC internal dengan resolusi 10 bit sebanyak 8
channel
4. Port komunikasi serial USART dengan kecepatan maksimal 2.5 Mbps
5. Mode Sleep untuk penghematan penggunaan daya listrik
6. RISC
ATmega 8535
1. Saluran IO sebanyak 32 buah, yaitu Port A, Port B, Port C dan Port D
2. ADC 10 bit sebanyak 8 Channel Tiga buah timer / counter
3. 32 register
4. Watchdog Timer dengan oscilator internal
5. SRAM sebanyak 512 byte
6. Memori Flash sebesar 8 kb
7. Sumber Interrupt internal dan eksternal
8. Port SPI (Serial Pheriperal Interface)
9. EEPROM on board sebanyak 512 byte
10. Komparator analog
11. Port USART (Universal Shynchronous Ashynchronous Receiver Transmitter)
Fitur ATMega 8535
ATmega 328
1. RISC
2. Memiliki EEPROM Electrically Erasable Programmable Read Only Memory
sebesar 1KB sebagai tempat penyimpanan data semi permanen karena
EEPROM tetap dapat menyimpan data meskipun catu daya dimatikan
3. Memiliki SRAM Static Random Access Memory sebesar 2KB.
4. Memiliki pin IO digital sebanyak 14 pin 6 diantaranya PWM Pulse Width
Modulation output.
5. 32 x 8-bit register serba guna
6. Dengan clock 16 MHz kecepatan mencapai 16 MIPS.
7. 32 KB Flash memory dan pada arduino memiliki bootloader yang
menggunakan 2 KB dari flash memori sebagai bootloader.
8. 130 macam instruksi yang hampir semuanya dieksekusi dalam satu siklus
clock.