Kepada Yth :
QUOTATION
PT. SINAR TIMUR DAYACIPTA
Date : Mei 24, 2018
Jl. Lingkar Selatan No. 88, Kampung Baru Asih, Muncul
Serpong Tangerang Selatan
No : SKQT-1805K-24
Lokasi : Serpong Tangerang Selatan
Sesuai dengan pertemuan kita mengenai pengadaan dan pemasangan lift SAKURA, untuk proyek di atas, mohon
perkenankan kami untuk menyampaikan penawaran sebagai berikut :
2 Jasa Instalasi, Test Commisioning 3 Lantai / 1 SET IDR 30.000.000 IDR 30.000.000
3 stops
Harga penawaran di atas adalah berdasarkan nilai tukar USD terakhir dengan toleransi +/-5%, apabila nilai tukar
diluar batas toleransi, maka kami berhak melakukan penyesuaian sesuai keadaan nilai tukar terbaru.
Harga diatas tidak termasuk pengerjaan sipil.
Harga diatas sudah termasuk PPN 10%
KETENTUAN PEMBAYARAN
Person 15 Person
Control AC-VVVF
Travel - Meter
CABIN SPECIFICATION
Display / Character : Standard Type /1.2.3 Jamb : Pattern Steel / Narrow Jamb
FEATURE (INCLUDED):
www.sakuraelevator.co.id
PT. SAKURA ELEVATOR INDONESIA CORP
In case of a power failure and the car stops between floors, on restoration of
Power-on Re-leveling power, the car will move to the nearest floor ✔
In the event of power failure, emergency lighting in the car will automatically
Emergency Car Lighting turn on. ✔
When switching from inspection mode back to normal operation, the door will
Door Safety Detector open and close to detect any obstructions. If detected the Elevator will not ✔
return to normal operation until the fault has been rectified
When the Elevator electrical safety circuit is open the Elevator will immediately
Safety Circuit Detector stop until the fault is rectified. ✔
Cancel Error-Carry If someone pushed the wrong button, just push it once more and it would be
Function cancelled. ✔
Automatic Turn Off Control panel will be turn off automatically in case there is no hall or car call to
Control Panel save energy. ✔
Fan will be turn off automatically in case there is no hall call or car call to save
Automatic Turn Off Fan energy. ✔
Car illumination will turn off automatically in case there is no hall call or car call
Automatic Turn Off light to save energy. ✔
The Elevator will return to the designated floor to stand by after responding to
Elevator Homing all calls. ✔
For instance, when a car call is being called to 8th floor and if the 8th floor¡¯s
Auto Time-Extending hall call is being called at the same time, the door open timing will automatically
Door Holding Function extend 3-5 sec from the original door open timing which allows ample time for ✔
passengers to enter and exit the Elevator.
If an obstacle prevents the door from closing, the door will repeatedly open and
Door Nudging Feature close until the object is removed. ✔
Mounted on the leading edge of the car door, causes the door and landing
Door Reversal Device doors to reopen if obstructed. ✔
When overload is detected it will send a warning signal and only when the load
Over-Load Device is reduced to safe parameters will the elevator resume service. ✔
When the Elevator detects that more car calls have been registered than the
Anti-Nuisance measured weight in the car the control panel will cancel all the car calls. ✔
When the car completes the last upward or downward direction change, the
Wrong Direction Car Call system will automatically detect and cancel the wrong direction can still stored
Back Cancelling ✔
in the memory.
When a car stops between floors due to mechanical malfunction, it will descend
Safety Operation to the nearest floor at a low speed and hold the doors open after checking all ✔
safety measures.
The device can cause the door to return to the fully open position, should the
Safety Door Edge door encounter a person or obstacle while closing. ✔
Though interphone service, passengers in the car are able to communicated
Intercom System with the control room. ✔
In the case of power failure, the ARD will pick up the signal and send the
Auto Rescue Device Elevator car to the nearest landing and open the door, allowing the passenger
(ARD) ✔
to exit the Elevator car.
www.sakuraelevator.co.id
PT. SAKURA ELEVATOR INDONESIA CORP
Gedung Metro Sunter Lt.3 Jln. Danau Sunter Utara Blok A2
Phone : (62)-21-29562206 Fax : (62)-21-29461007
LINGKUP PEKERJAAN
JADWAL PENGADAAN
CATATAN
c Jaminan atas kesalahan bahan dan pembuatan pabrik (workmanship) adalah 12 (dua belas) bulan sejak barang
dikapalkan apabila pemeliharaannya dilakukan oleh kami.
d Penawaran ini berlaku 1(satu) bulan sejak tanggal surat penawaran ini dan harus ada penegasan dari setelah
tanggal tersebut diatas.
Semoga penawaran harga ini dapat memenuhi kebutuhan Bapak/Ibu, dan atas perhatiannya kami ucapkan terima
kasih. Bila diperlukan keterangan yang lebih lengkap kami selalu bersedia memberikan penjelasan.
Hormat Kami,
Kalyana Wira
(Sales Department)
Hp.081905076621
Untuk Pembayaran / Down Payment (DP)
harap ditransfer ke Rekening :