Anda di halaman 1dari 8

SENARAI SEMAK CALON

CANDIDATTES, CHECK LIST


ARAHAN
Anda tidak dibenarkan bekerja dengan radas bagi lima minit yang pertama. Tempoh ini hendaklah
digunakan untuk menyemak senarai radas, membaca soalan dan merancang eksperimen yang akan
digunakan. Tandakan ( √ ) pada ruangan kotak yang disediakan untuk menyemak bahan dan radas yang
disediakan dan dibekalkan.

Instruction
You are not allowed to work with apparatus in first five minutes. This period is used to check the
apparatus list, read the question and plan the experiment which will carry out. Mark ( √ ) in the box
provided to check the materials and apparatus prepared and supplied.

Bil. Kuantiti Ya ( √ ) / Tidak ( √ )


Radas/Bahan
No. Quantit Yes ( √ ) / No ( √ )
Apparatus/Material
y
1. Bekalan kuasa 1 ( )
Power supply
2. pemanas rendam 1 ( )
immersion heater
3. Bikar 1 ( )
beaker
4. jam randik 1 ( )
stopwatch
5. Termometer 1 ( )
thermometer
6. kaki retort 1 ( )
retort stand
7. neraca elektronik 1 ( )
electronic balance
8. Kertas tisu 1 ( )
Tissue paper
Anda dikehendak menjalankan satu eksperimen untuk menentukan muatan haba tentu air
You are required to carry out an experiment to determine specific heat capacity

Jalankan eksperimen dengan menggunakan langkah-langkah di bawah:


Carry out the experiment by using the stepd below:

1. Balut bikar dengan kertas tisu.


Wrap a beaker with tissue paper.
2. Letakkan bikar di atas neraca elektronik dan set semula bacaan neraca itu kepada nilai sifar.
Place the beaker on top of an electronic balance and reset the reading of the balance to zero.
3. Isi air ke dalam bikar sehingga tiga per empat penuh.
Fill the beaker with water until it is three-quarter full.
4. Ambil bacaan jisim air, m yang ditunjukkan oleh neraca elektronik. Rekodkan bacaan anda.
Record the reading of the mass of the water, m shown on the electronic balance.
5. Sediakan susunan radas seperti yang ditunjukkan dalam Rajah 4.10.
Set up the apparatus as shown in Figure 4.10.
6. Ambil bacaan suhu awal air, θ1. Rekodkan bacaan anda.
Record the initial temperature of the water, θ1
7. Hidupkan pemanas rendam dan pada masa yang sama, mulakan jam randik.
Switch on the immersion heater and start the stopwatch at the same time.
8. Perhatikan perubahan bacaan termometer.
Observe the change in the thermometer reading.
9. Selepas masa lima minit, matikan pemanas rendam. Ambil bacaan termometer tertinggi sebagai
suhu akhir air, θ2. Rekodkan bacaan anda.
After five minutes, switch off the immersion heater. Record the highest thermometer reading as
the final water temperature, θ2 .
(a) Berdasarkan eksperimen yang dijalankan, dapatkan:
Based on the experiment conducted, find :

Kuasa pemanas rendam, P / W

Power of immersion heater, P / W

Masa pemanasan, t / s

Heating time, t / s

Jisim air, m / kg

Mass of water, m / kg

Suhu awal air, θ1 / °C

Initial temperature of water, θ1 / °C

Suhu akhir air, θ2 / °C

Final temperature of water, θ2 / °C

[5 markah / marks]

(b) Pt
Hitungkan muatan haba tentu air menggunakan rumus, c =
m(θ 2−θ 1)

Pt
Calculate the specifi c heat capacity of water using the formula, c =
m(θ 2−θ 1)

[2 markah / marks]
(c) Mengapakah bikar itu perlu dibalut dengan kertas tisu?
Why does the beaker need to be wrapped with tissue paper?

_____________________________________________________________________________
[1 markah / mark]

(d) Mengapakah suhu air akhir, θ2 tidak diambil sebaik sahaja masa pemanasan lima minit tamat?
Why is the fi nal water temperature, θ2 not taken as soon as the fi ve-minute heating time ends?

______________________________________________________________________________
[1 markah / mark]

(e) Cadangkan langkah-langkah untuk meningkatkan kejituan keputusan eksperimen ini.


Suggest methods to increase the accuracy of the result of this experiment.

_____________________________________________________________________________
[1 markah / mark]
SENARAI SEMAK CALON
CANDIDATTES, CHECK LIST
ARAHAN
Anda tidak dibenarkan bekerja dengan radas bagi lima minit yang pertama. Tempoh ini hendaklah
digunakan untuk menyemak senarai radas, membaca soalan dan merancang eksperimen yang akan
digunakan. Tandakan ( √ ) pada ruangan kotak yang disediakan untuk menyemak bahan dan radas yang
disediakan dan dibekalkan.

Instruction
You are not allowed to work with apparatus in first five minutes. This period is used to check the
apparatus list, read the question and plan the experiment which will carry out. Mark ( √ ) in the box
provided to check the materials and apparatus prepared and supplied.

Bil. Kuantiti Ya ( √ ) / Tidak ( √ )


Radas/Bahan
No. Quantit Yes ( √ ) / No ( √ )
Apparatus/Material
y
1. Bekalan kuasa 1 ( )
Power supply
2. pemanas rendam 1 ( )
immersion heater
3. Bikar 1 ( )
beaker
4. jam randik 1 ( )
stopwatch
5. Termometer 1 ( )
thermometer
6. kaki retort 1 ( )
retort stand
7. neraca elektronik 1 ( )
electronic balance
8. Kertas tisu 1 ( )
Tissue paper
Anda dikehendak menjalankan satu eksperimen untuk menentukan muatan haba tentu air
You are required to carry out an experiment to determine specific heat capacity

Jalankan eksperimen dengan menggunakan langkah-langkah di bawah:


Carry out the experiment by using the stepd below:
1. Sediakan susunan radas seperti yang ditunjukkan dalam Rajah 4.11.
Set up the apparatus as shown in Figure 4.11.
2. Ambil bacaan suhu awal blok aluminium, θ1 dan rekodkan bacaan anda. 2.
Record the initial temperature of the aluminium block, θ1
3. Hidupkan pemanas rendam dan pada masa yang sama, mulakan jam randik.
Switch on the immersion heater and start the stopwatch at the same time
4. Selepas masa lima minit, matikan pemanas rendam. Ambil bacaan tertinggi termometer sebagai
suhu akhir aluminium blok, θ2. Rekodkan bacaan anda.
After five minutes, switch off the immersion heater. Record the highest thermometer reading as
the fi nal temperature of the aluminium block, θ2
(a) Berdasarkan eksperimen yang dijalankan, dapatkan:
Based on the experiment conducted, find :

Kuasa pemanas rendam, P / W

Power of immersion heater, P / W

Masa pemanasan, t / s

Heating time, t / s

Jisim air, m / kg

Mass of water, m / kg

Suhu awal air, θ1 / °C

Initial temperature of water, θ1 / °C

Suhu akhir air, θ2 / °C

Final temperature of water, θ2 / °C

[5 markah / marks]

(b) Pt
Hitungkan muatan haba tentu air menggunakan rumus, c =
m(θ 2−θ 1)

Pt
Calculate the specifi c heat capacity of water using the formula, c =
m(θ 2−θ 1)

[2 markah / marks]
(c) Mengapakah bikar itu perlu dibalut dengan kertas tisu?
Why does the beaker need to be wrapped with tissue paper?

_____________________________________________________________________________
[1 markah / mark]

(d) Mengapakah suhu air akhir, θ2 tidak diambil sebaik sahaja masa pemanasan lima minit tamat?
Why is the fi nal water temperature, θ2 not taken as soon as the fi ve-minute heating time ends?

______________________________________________________________________________
[1 markah / mark]

(e) Cadangkan langkah-langkah untuk meningkatkan kejituan keputusan eksperimen ini.


Suggest methods to increase the accuracy of the result of this experiment.

_____________________________________________________________________________
[1 markah / mark]

Prosedur :

Anda mungkin juga menyukai