ABSTRACT
A wind turbine is a kind of wind mill that used to generate electricity. The
work principle of a wind turbine is by changing kinetic energy of the wind into the
mechanical energy of the turbine’s rotor to drive the generator. The aim of this
research is to design a portable wind turbine power generation. There are file steps
were done in this research that are literature study, collecting the initial data of the
wind velocity, designing the product, evaluating the design and making animations
of the assembly process and the operational process of the product.
This product is designed to run at 4,2 m/s – 8,3 m/s of the wind velocity,
with the output power between 10 W – 50 W. Main components of this product are
generator house, generator, planetary gearbox, bearing house, turbine shaft, hub,
radial arms, turbine blades, turbine supports, water pass, and DC adaptor. The
design model of this product can be developed as the product that can be used to
charge power of cellular phone, camera, power bank, and any other electronic
portable devices.
Keywords : Wind turbine, portable, compact, design model, animation
telepon seluler masa kini senang Manfaat pertama adalah penelitian ini
Pada penelitian ini akan dibuat peneliti yaitu sebagai salah satu syarat
vt = ω R ................................... (2.10)
2.5. Generator DC
Generator DC merupakan
Gambar 2.3 Koefisien Kinerja
sebuah perangkat mesin listrik
Daya dan tip speed ratio dengan
Variasi Jumlah Sudu (Hau, 2013) dinamis yang mengubah energi
mekanis menjadi energi listrik.
2.4.7. Solidity
(Generator DC, Adiyatma).
Solidity adalah rasio antara
total luas platform sudu dengan luas
penampang aliran (Hau, 2013).
nHc
σ= ..................................... (2.11)
S
3. METODOLOGI
Gambar 3.1 Diagram Alir Prosedur
PENELITIAN
Penelitian
3.1. Tempat dan Waktu
Penelitian
Penelitian ini dilakukan dalam
beberapa tahap dari bulan Februari
2020 sampai bulan Juli 2020.
Perancangan dilakukan di
Laboratorium Jurusan Teknik Mesin,
Fakultas Teknik, Universitas Sam
Ratulangi
Gambar 3.2 Diagram Alir
Perancangan Produk
3.2. Alat Penelitian
.
Alat yang digunakan pada
3.4. Data Klimatologi
penelitian adalah Perangkat lunak
Data klimatologi (kecepatan
Ansys Workbench untuk simulasi
angin, temperature, dan lain-lain)
CFD(Computation Fluid Dynamic)
diperoleh dari website Badan Pusat
dan Perangkat lunak yang kedua
Statistik (www.bps.go.id). Data
adalah Autodesk Inventor.
vertikal. ≈ 0,8 m2
Nilai Luas area yang diperoleh adalah
Besar gaya lift pada satu blade output pada kecepatan angin 8,3 m/s
Perhitungan
Poros
398 MPa
10,7 MPa ≤
2,5
Gambar 4.5 Hasil simulasi: tegangan 10,7 MPa ≤ 159,2 MPa.