PT TORISHIMA GUNA ENGINEERING Revisi 0 Bagian IK 5.7.1 - 145
NON DESTRUCTIVE TEST (NDT)
1. Instruksi kerja ini melingkupi persyaratan-persyaratan untuk melakukan
Nondestructive Testing / NDT yang digunakan untuk menentukan kehadiran discontinuities permukaan dan di dalam material atau part, dengan menggunakan teknik yang tidak mengganggu terhadap fungsi dari part itu sendiri. This work instruction covers the requirements for conducting nondestructive tests used in determining the presence of surface and internal discontinuities in materials or parts using techniques that do not impairserviceability.
2. Metoda NDT yang tersedia di TSID adalah Penetrant, Magnetic Particle
dan Ultrasonic Testing. MetodametodaNDT tersebut harus dikerjakan oleh personel NDT yang diserifikasi sesuai dengan practice SNT TC 1A untuk sertifikasi personal NDT. The NDT Methods available in TGE are Penetrant Testing, Magnetic Particle Testing and Ultrasonic Testing. Those NDT methods should be performed by certified NDT personnel in accordance with SNT TC 1A recommended practice for NDT Personnel Certification.
3. Metoda NDT lain seperti Eddy Current atau Radiography Testing
merupakan metoda tambahan yang dipakai apabila dibutuhkan untuk penelitian lanjut, sesuai ketentuan gambar kerja atau konstruksi manufactur, atau pengganti 3 metoda NDT yang ada di TGE The other NDT methods such as Eddy Current or Radiography Testing are additional methods which are applied if required for further investigation, as specify on the drawing or manufacturing instruction, or substituted of other 3 TGE NDT methods due to ineffective method reason, etc. In this case TGE will be designate to a NDT outside agency.
Ditinjau Disetujui Revisi Tanggal Ditinjau Disetujui
1 2 3 Hal: 1 / 2 INSTRUKSI KERJA Edisi A Tanggal 11 June 2015 PT TORISHIMA GUNA ENGINEERING Revisi 0 Bagian IK 5.7.1 - 145
4. Pilih dan tentukan metoda-metoda yang dipakai berdasarkan kepada jenis
dan arah discontinuities yang dicurigai, material, kondisi benda uji, dan lain sebagainya. Tentukan oleh level III atau level III beserta Engineering dan juga atas permintaan customer atau persetujuan antara TGE dan customer. Select and determine the methods applies based on type and direction of discontinuity sought, material, part condition, etc. then decided by Level III or Level III and Engineering and by customer request or agreement between TGE and customer.
Ditinjau Disetujui Revisi Tanggal Ditinjau Disetujui