c.faktor tekuk … error O/S #5 Column factored load exceed Euler force / ratio
kolomnya kepanjangan ,, solusi beri pengaku tengah
c. gaya geser combinasi dengan gaya torsi menyebabkan melampaui batas iji
solusi : dimensi dimensi dibuat lebih besar akan lebih baik
O/S #45 Shear due to shear force and torsion together exceeds maximum limit
Sebaiknya sih jangan diabaikan, andaikata mau diabaikan juga boleh tapi
dicek lagi barangkali di design preferences ratio limit masih 0,95 ganti ke 1
*kalau cukup berani
ya kalau pun enggak, cek aja momen momen kolom di software buat cek
kolom seperti spcolumn atau pcacol. Kalau dari diagram interaksi masih ok,
ya bisa dijadikan pertimbangan lah.
Error yang lain adalah O/S #3, yaitu penampang balok tidak kuat menahan
gaya geser yang terjadi. Tulangan yang dibutuhkan melebihi maksimum yang
diperbolehkan
“Expected yield (Fye) and expected tensile (Fue) stresses are the product of a
code-prescribed factor and the expected strength of the material. This factor is
typically around 1.1, as with FEMA 356 Table 5-3. These effective stress values
represent the material response which occurs approximately halfway along the
x-axis of the force-deformation relationship. FEMA 356 recommends using
effective strength for deformation-controlled actions. Minimum strength
represents the lower bound of nonlinear material response, which is best for
force-controlled actions. Expected stress values are used to automatically
generate hinge properties for P-M2-M3 and P-M hinges.”
FYE dan FUE adalah hasilkali faktor dengan tegangan efektif material .
dengan nilai faktor 1.1 menurut FEMA , tentu ini perlu dicerna dengan baik
karena menaikkan kemampuan material itu 1.1 lebih kuat (expected =
diharapkan)