Muhammad Dieter K.D - 22508334078-1
Muhammad Dieter K.D - 22508334078-1
D4 TEKNIK MESIN
FAKULTAS
VOKASI
DEPARTEMEN TEKNIK MESIN
OTOMOTIF UNIVERSITAS NEGERI
YOGYAKARTA 2022/2023
Chapter IV
False 3. Because of the low permeability of steel, the field strength is greater within a
nonmagnetic conductor as compared to a magnetic conductor,
- Permeabilitas adalah properti material yang menentukan seberapa mudah suatu material
dapat menjadi magnet di hadapan medan magnet. Bahan magnetik, seperti besi dan baja,
memiliki permeabilitas yang tinggi, yang berarti bahan tersebut dapat dengan mudah
menjadi magnet dan meningkatkan kekuatan medan magnet.
False 4. The field strength outside a solid conductor is the same with either
a magnetic or nonmagnetic conductor.
- Kekuatan medan di luar konduktor padat belum tentu sama untuk konduktor
magnetik dan konduktor nonmagnetik ketika mengalami kondisi yang sama. Perilaku
medan
magnet di dalam dan di sekitar konduktor bergantung pada berbagai faktor, termasuk
sifat material dan geometri konduktor.
False 7. Point A in the sketch best describes the maximum peak strength within
the magnetic field.
True 8. In the sketch shown, the D level best describes the field strength of two times the radius.
False 9. The field strength (F) would be at the same comparative level for both magnetic
and nonmagnetic bars.
False 10. The field strength illustrated best describes a hollow magnetic conductor with high
permeability.
True 11. The sketch illustrates that AC was probably used as the magnetizing current.
True 12. Point A would drop to the B level if the bar were solid instead of hollow.
Chapter V
False 1. If the operator has a question as to the proper amperage to use, it is always
safe to use the maximum output of the machine.
- Menggunakan output maksimum mesin tanpa mempertimbangkan persyaratan
spesifik tugas dapat berbahaya dan dapat menyebabkan kelebihan beban listrik,
kerusakan peralatan, atau bahkan bahaya keselamatan.
True 6. As a general rule, when the part is longer than 18 inches, more than one
head shot should be used.
True 8. The prods should be placed on the part so that the field produced is in
the same direction as the suspected defects.
True 9. As the prod spacing is increased (e.g., from 4 to 8 inches), the amperage
should be decreased because the two fields produced are then in less
conflict with each other.
True 10. A part that has been inspected with the magnetic particle method
may cause problems during welding if it is not properly demagnetized.
True 12. Field indicators can be effective in determining if the specimen contains
a circular magnetic field.
True 13. Demagnetization is essentially a matter of reducing the magnetic field and
then reversing it.
True 14. Because of the automatic current reversal, alternating current is usually preferred
for demagnetization units.
False 15. When an article is demagnetized, the best results will be obtained if
the demagnetizing unit faces north and south.
- Efektivitas demagnetisasi terutama bergantung pada sifat dan konfigurasi
unit demagnetisasi dan prosedur demagnetisasi itu sendiri.
True 16. The cables of a portable magnetic particle unit could be wrapped into a
coil which could be used for demagnetization.