03elektronik Soalan
03elektronik Soalan
Chapter 4 Form 5
1.
Elektronik
Electronics
Kertas I
Paper I
Thermistor
Termistor
Diagram 14 / Rajah 14
What happens to the resistance of the thermistor and the light bulb when the
temperature surrounding the thermistor increases?
Apakah yang berlaku kepada rintangan termistor dan mentol itu apabila suhu di
sekeliling termistor itu bertambah?
( Aras :Tinggi)
Resistance of thermistor
Rintangan termistor
A
B
C
D
Decreases
Berkurang
Decreases
Berkurang
Increases
Bertambah
Increases
Bertambah
Light bulb
Mentol
Lights up
Bernyala
Does not light up
Tidak bernyala
Lights up
Bernyala
Does not light up
Tidak bernyala
Bab 4 Tingkatan 5
Chapter 4 Form 5
2.
Elektronik
Electronics
Kertas I
Paper I
Diagram 15 / Rajah 15
Which change in voltage would cause the bright spot on the screen to move upwards
as shown in the above diagram?
Perubahan voltan manakah akan menyebabkan kedudukan tompok cahaya di skrin
bergerak ke atas seperti ditunjukkan pada rajah di atas ?
( Aras :Tinggi)
A
B
C
D
Decreasing V1
Mengurangkan V1
Increasing V1
Menambah V1
Decreasing V2
Mengurangkan V2
Increasing V2
Menambah V2
R
Q
Bab 4 Tingkatan 5
Chapter 4 Form 5
3.
Elektronik
Electronics
Kertas I
Paper I
Diagram 16 shows a logic gate circuit which has two inputs, P and Q.
Rajah 16 menunjukkan satu litar get logik yang mempunyai dua input, P dan Q.
P
Diagram 16 / Rajah 16
Which of the following input and output are correct?
Manakah antara input dan output berikut yang betul?
( Aras :Tinggi)
Input
A
B
C
D
4.
Output
0
1
0
1
0
0
1
1
0
1
0
1
Diagram 17 shows the output waveform on cathode ray oscilloscope (CRO) screen.
Rajah 17 menunjukkan bentuk gelombang output pada skrin osiloskop sinar katod
(OSK).
Diagram 17 / Rajah 17
Which circuit will display the output waveform shown in Diagram 33?
Litar yang manakah akan mempamerkan bentuk gelombang output Rajah 33?
( Aras :Tinggi)
Bab 4 Tingkatan 5
Chapter 4 Form 5
Elektronik
Electronics
5.
Kertas I
Paper I
Bab 4 Tingkatan 5
Chapter 4 Form 5
6.
Elektronik
Electronics
Kertas I
Paper I
R2
Diagram 19 / Rajah 19
What changes should be done to light up the bulb during the day time?
Apakah perubahan yang perlu dilakukan untuk menyalakan mentol pada waktu siang?
( Aras :Tinggi)
A
B
C
D
7.
Interchange R1 and R2
Tukar antara R1 and R2
Reverse the terminal of the battery
Songsangkan terminal bateri
Replace the npn transistor with a pnp transistor
Ganti transistor npn dengan transistor pnp
Replace resistor R3 with a resistor of lower resistance
Ganti perintang R3 dengan perintang yang lebih rendah rintangan.
Diagram 20 shows a logic gate circuit which has two inputs, X and Y.
Rajah 20 menunjukkan satu litar get logik yang menpunyai dua input, X dan Y.
Bab 4 Tingkatan 5
Chapter 4 Form 5
Elektronik
Electronics
Kertas I
Paper I
If the logic state of X is 0 and the logic state of Y is 1, what are the logic states at P, Q
and R?
Jika keadaan logik X ialah 0 dan keadaan logik Y ialah 1, apakah keadaan logik bagi
P,Q dan R ?
( Aras :Tinggi)
A
B
C
D
8.
0
0
1
1
0
1
1
0
1
1
0
1
What is the peak voltage and the frequency of the alternating current supply that
connected to the C.R.O?
Apakah voltan puncak dan frekuensi arus ulang alik yang disambungkan ke OSK?
( Aras :Tinggi)
A
B
C
D
Peak voltage / V
Voltan puncak / V
9.0
6.0
4.5
9.0
Frequency / Hz
Frekuensi / Hz
40
40
40
80
Bab 4 Tingkatan 5
Chapter 4 Form 5
9.
Elektronik
Electronics
Kertas I
Paper I
Diagram 21 shows a combination of logic gates. The logic inputs of A, B and C are 1, 0
and 0 respectively.
Rajah 21 menunjukkan gabungan get logik, Input logik P, Q dan R adalah 1, 0 dan 0
masing - masing
Diagram 21 / Rajah 21
Which of the following are the correct logic output at X and Y?
Antara berikut yang manakah betul bagi logik output pada X dan Y?
( Aras :Tinggi)
10. Diagram 22 shows a shadow on the screen of a Maltese Cross Tube when the 6.3 V
power supply is switched on but the EHT power supply is off.
Rajah 22 menunjukkan bayang di atas skrin Tiub Palang Maltese apabila bekalan
kuasa 6.3 V dihidupkan tetapi bekalan kuasa VLT dimatikan.
Fluorescent screen
Skrin pendarfluor
Diagram 22 / Rajah 22
Bab 4 Tingkatan 5
Chapter 4 Form 5
Elektronik
Electronics
Kertas I
Paper I
When the EHT supply is switched on, the shadow remains but the fluorescent screen
becomes green in colour.
Which statement cannot be inferred from this observation?
Apabila bekalan kuasa VLT dihidupkan, bayang itu kekal tetapi skrin pendarfluor
menjadi berwarna hijau.
Pernyataan manakah tidak boleh diinferens daripada pemerhatian ini?
( Aras :Tinggi)
A
B
C
D