Relay) was made. This time, a 3-phase electric motor control for the Star Delta circuit with
Omron brand CP1E PLC (Programmable Logic Controller) will be made according to the
author's.
To remind you again, the following is a 3-phase electric motor control circuit, Star Delta
circuit with TDR:
Sebelumnya telah dibuat kontrol motor listrik 3 fasa untuk rangkaian Star Delta dengan
TDR (Time Delay Relay). Kali ini akan dibuat sebuah kontrol motor listrik 3 fasa untuk
rangkaian Star Delta dengan PLC (Programmable Logic Controller) merk Omron sesuai
dengan yang penulis buat.
Untuk mengingatkan kembali, berikut ini adalah rangkaian kendali motor listrik 3 fasa
rangkaian Star Delta dengan TDR :
The TDR components above are changed with PLC components as below:
Komponen TDR di atas diubah dengan komponen PLC seperti di bawah ini:
In the circuit above, it can be seen that the Start button is connected to input 00 and the Stop button
is connected to input 00, while the output 00 is to activate the K1 contactor, output 01 is to activate
the K2 contactor, output 02 is to activate the K3 contactor.
For a 3-phase star delta electric motor power circuit using a PLC controller is the same as using a
TDR, as shown below.
Pada rangkaian diatas terlihat tombol Start terhubung ke input 00 dan tombol Stop
terhubung ke input 00, sedangkan output 00 untuk mengaktifkan kontaktor K1, output
01 untuk mengaktifkan kontaktor K2, output 02 adalah mengaktifkan kontaktor K3.
Untuk rangkaian daya motor listrik star delta 3 fasa menggunakan kontroler PLC
sama dengan menggunakan TDR, seperti gambar dibawah ini.
The control circuit using a PLC is simpler in wiring, because the form of the wiring is
changed in the form of a program, one of which is in the form of a ladder program. Take a
look at the two control circuits below.
bentuk pengkabelan diubah dalam bentuk program salah satunya berupa program
can be in the form of a ladder that matches the input and output circuits that are made, as shown
below:
If the 3 Phase Electric Motor wants to stop rotating according to the specified time, then
the ladder program on the PLC can look like the picture below.
Program ladder di atas membuat motor listrik berputar dimulai dari rangkaian start,
kemudian dalam waktu 50 detik akan berubah menjadi rangkaian delta hingga tombol
Stop ditekan.
Jika Motor Listrik 3 Fasa ingin berhenti berputar sesuai waktu yang ditentukan, maka
program ladder pada PLC dapat terlihat seperti gambar di bawah ini.
The ladder program above will make the electric motor rotate with the delta circuit, then within a certain
time it changes to the Star circuit, then changes again to the Delta circuit, finally the electric motor will stop
Program ladder di atas akan membuat motor listrik berputar dengan rangkaian delta,
kemudian dalam waktu tertentu berubah menjadi rangkaian Star, kemudian berubah
lagi menjadi rangkaian Delta, akhirnya motor listrik akan berhenti berputar dengan
sendirinya.