Quantitatif Log Analysis Simple
Quantitatif Log Analysis Simple
CONTENTS
Undisturbed Reservoir
INVASION PROFILE
Invasion Profiles
Notes:
1.
Rxo > Rt
2.
Dalam formasi
yang porositasnya
tinggi dan Sh-nya
tinggi pula akan
timbul annulus
(hanya berumur
beberapa hari
saja)
Petrophysical Properties
Parameter parameter batuan
Yang
Asumsi:
Matrix batuan tidak menghantarkan arus listrik.
Ini berarti hantaran listrik sepenuhnya dilakukan
melalui air dalam pori-pori.
Ini dimungkinkan karena air tadi mengandung NaCl.
Jadi: Batuan yang mengandung air punya high
conductivity (atau low resistivity).
1
Note:
conductivity = -------------------------resistivity
Environmental Correction
Temperature Calculation
1. PERHITUNGAN SUHU FORMASI
D x (BHT-Ts)
Tf =
+ Ts
Td
Tf
D
Td
Ts
: suhu formasi (o F)
: kedalaman formasi yang diukur
: kedalaman total
: suhu permukaan (o F)
x R1
Tf + 6.77
0.16 Ohm-m
0.052 Ohm-m
25C
120C
Chart Gen-9
Metode Menghitung Rw
Rw dari SP, SP= -K log (Rmfe/Rwe); K=61+0.13 TF
X-plot phi vs Res, Hingle Plot, Picket Plot
Metode Rasio, Rw = (Rt/Rxo).Rmf
Rw(a) = Rt/F
Rw dari EPT, Rw <= (Phi-EPT)^2 . Rt
Sumber lain:
Katalog
Well testing
m calculation
Variasi harga m dan n sangat besar.
Table 6-1 disusun untuk lapangan-lapangan di Amerika dari
data core.
Untuk formasi sandstone:
m bervariasi dari 1.5 sampai 2.0
n bervariasi dari 1.3 sampai 2.2
variasinya cukup besar meskipun harga rata-ratanya
sekitar 2
Harga cementation exponent m sangat dipengaruhi oleh
bentuk butiran (grain shape):
Cementation exponent: m
Slope = -m
a
0.01
(log scale)
1.0
m pada carbonate
1.
2.
m ---------------,
log t
3.
m = t vug ,
vug= 2(t s)
Water Saturation : n
n is saturation dependent
in fresh water, the error
due to variation on n
decreases at higher
saturations.
n measurements can be
made on core, but they are
difficult and expensive.
n may also be saturation
equation dependent.
MULTIMINERAL IDENTIFICATION
Volume mineral-mineral dapat ditentukan dengan log
density, neutron, sonic dan spectral gamma ray.
Mineral-mineral yang penting adalah :
sandstone, limestone, dolomite (dan anhydrite).
Komponen-komponen yang mengganggu adalah shale
dan mineral-mineral yang lebih jarang ditemui: gypsum,
salt, polyhalite dan sulfur.
Untuk menentukan (
ma)a dipakai fig 6-8 dimana telah
ditarik garis-garis yang punya harga (
ma)a konstan.
Data b dan N dipakai sebagai input.
Untuk menentukan (t ma)a dipakai chart yang diperlihatkan pada fig 6-9.
Harga-harga (
ma)a dan (t ma)a lalu dimasukkan kedalam
chart fig 6-7.
Contoh: titik B adalah campuran dolomite-calcite.
(6.10)
Porosity calculation
5. PERHITUNGAN POROSITAS
a. D (Porositas dari log Densitas)
ma - b
D=
ma - f
D : porositas
ma : densitas matriks
b : densitas bulk (batuan), dari log
f : densitas fluida
b. N (Porositas dari log Neutron)
N untuk LS langsung dibaca dari log,
untuk litologi lain;
N = Nlog + 4 %
Hydrocarbons:
Secara umum dianggap bahwa hydrocarbons tidak
memberikan pengaruh yang signifikan terhadap harga
transit time.
Fractures/Vugs:
Log Sonic tidak melihat fractures dan vugs, karena hanya membaca primary porosity yang lebih kecil dari total
Porosity (
T)
Beda porositas total dengan porositas sonic S adalah
secondary porosity.
Secondary Porosity Index
SPI = (
T - S)/ T
7. KOREKSI PERHITUNGAN
a. koreksi Densitas
Dcorr = D - ( Dclay . V shale)
Dcorr : Porositas-Densitas terkoreksi
D : harga porositas hasil perhitu-ngan dari log densitas
Dclay : harga porositas hasil perhitu-ngan dari log densitas untuk zona clay
terdekat
V shale : volume serpih
b. koreksi Neutron
Ncorr = N - Nclay . V shale)
Ncorr : Porositas-Neutron terkoreksi
N : harga porositas hasil perhitu-ngan dari log neutron
Nclay : harga porositas hasil perhitu-ngan dari log neutron untuk zona clay
terdekat
V shale : volume serpih
c. Porositas Gabungan
i =
i : porositas gabungan
Dcorr : Porositas-Densitas terkoreksi
Ncorr : Porositas-Neutron terkoreksi
Calculation of Sw
6. PERHITUNGAN Sw
a. Persamaan Archie
F = Ro / Rw
F = a / m
F : Formation volume factor
Ro : tahanan jenis formasi yang hanya berisi air (ohmm)
Rw : tahanan jenis air formasi (ohmm)
a : konstanta sementasi (ss : 0.81 ; ls : 1.0)
m : eksponen sementasi (2)
Vw
Porosity,
Vo
Sw = Vw /
So = Vo /
b. Resistivity Index
I = Rt /Ro
I = 1 / Sw2
I : Resistivity Index
Rt
: tahanan jenis formasi yang berisi oil dan air (ohmm)
Ro
: tahanan jenis formasi yang hanya berisi air (ohmm)
Sw
: saturasi (kejenuhan) air (%)
a. Saturasi Air (Sw)
sandstone
Sw = (0.9 / ) . Rw/Rt
limestone
Sw = (1 / ) . Rw/Rt
(7.11)
(7.12)
(7.13)
(7.14)
(7.15)
Inilah persamaan untuk menghitung water saturation dalam metode Dual Water.
m
1.4
1 Vcl
e 2 n
=
+
Sw
Rt
R
aRw
cl
Nigeria Equation
1Vcl
1 Vcl 2
e 2
=
+
Sw
Rt Rcl
Rw
Indonesia Equation
Waxman-Smits Equation
1 Sw
BQ S
= * + v* w
Rt F Rw
F
Ct =
tm S wtn
a
S
Cw + wb (C wb C w )
S wt
1.93m'Qv
Ct = m (1 0.28Qv )m' Cw +
n
0.7Sw
1+
Cw
1/ 2
m'
+
1
.
3
Qv
w +
1.93 m T QV
m
+
QV
0
T
1+0.7 T Sw-n /w
T =1+0.0414 T-22
m =1.62+1.37 QV
1/2
1-
Sen, P.N.; Goode, P.A.; and Sibbit, A.M.: Electrical conduction in clay bearing sandstones at low and high
salinities, Journal of Applied Physics 63 no.10 (15 May 1988), pp 4832-4840.
Sen, P.N.; Goode, P.A.:Influence of temperature on electrical conductivity in shaly sands, Geophysics 57 no. 1
(January 1992) pp 89-96.
Sen, P.N.; Goode, P.A.: Shaly sand conductivity at low and high salinities, presented at the 29th annual logging
symposium of the SPWLA (June 1988) paper F.
(Sxo-Sw)