Wire Feed
MIG = Metal Inert Gas
• Inert Gas= Inactive gas that does not combine
chemically with base or filler metal
MAG= Metal Active Gas
• Active Gas= Gas will combine chemically with
base or filler metal
V Groove U Groove
Knurled V groove Cogged U groove
Set Volts
• See Chart for proper setting
Set Wire Speed
• See Chart for proper setting
• Increase wire speed = Increase amps
• Decrease wire speed = Decrease amps
Set gas flow
• See Chart for proper setting
• Pull trigger to get gas flowing then adjust regulator
ER - 70S - 6
Chemical Composition
Electrode 6 = high silicon
Industri Otomotif
• Dapat mengelas sheet metal setipis 0.5mm
• Dapat dilakukan dengan robot
• Dapat di setup dengan sistem pengumpan kawat las yang kontinyu
Perkapalan
• Dapat digunakan untuk mengelas material yang tebal hingga 1 inch
• Dapat mengelas di luar workshop dengan menggunakan flux cored
welding wire
General repair shops
Railroad
Furniture
Structural steel in construction
PROGRAM STUDI TEKNIK PENGELASAN - PPNS
Nama-nama bagian dari nozzle
Arc voltage too high Proper arc voltage Arc voltage too slow
for travel speed. for speed for travel speed