CHAPTER 6: ELECTROCHEMISTRY
BAB 6: ELEKTROKIMIA
1 Based on the aqueous solution given, state the ions present in the solution.
Berdasarkan larutan akueus yang diberikan, nyatakan ion-ion yang hadir dalam
larutan.
(ii) Hydroxide ions, OH- are selectively discharged to form oxygen gas
and water by losing electrons.
Ion hidroksida, OH- dipilih untuk dinyahcas dengan melepaskan
electron
untuk membentuk gas oksigen dan air
Three factors that influence the selective discharge of ions at both electrodes.
Tiga factor yang mempengaruhi nyahcas secara pilihan ion di kedua-dua elektrod.
(a) Position of ions in electrochemical series
Kedudukan ion dalam siri elektrokimia
(b) Concentration of ions in the electrolyte
Kepekatan ion dalam elektrolit
(c) Types of electrodes used in the electrolysis
Jenis elektrod yang digunakan dalam elektrolisis
An electrolysis is carried out to the following aqueous solution using carbon electrodes.
Complete the table.
Elektrolisis dijalankan pada larutan akueus yang berikut dengan menggunakan elektrod
karbon. Lengkapkan jadual.
Ion-ion yang tertarik ke Ion NO3-, ion OH- Ion NO3-, ion OH-
anod
Ion that is selectively OH- ion OH- ion
discharged at the anode Ion OH- Ion OH-
Ion yang dipilih untuk
dinyahcas di anod
Reason OH-ion is below NO3- ion in OH-ion is below NO3- ion in
Sebab the electrochemical series the electrochemical series
Ion OH- berada di bawah Ion OH- berada di bawah
ion NO3- dalam siri ion NO3- dalam siri
elektrokimia elektrokimia
Observation Gas bubbles are produced. Gas bubbles are produced.
Pemerhatian Colourless gas is collected Colourless gas is collected
Gelembung gas terhasil. Gelembung gas terhasil.
Gas tidak berwarna Gas tidak berwarna
dikumpulkan dikumpulkan
Half equation 4OH- O2 + 2H2O + 4e 4OH- O2 + 2H2O + 4e
Persamaan setengah
Ions attracted to the cathode H+ ion, K+ ion H+ ion, Cu2+ ion
Ion-ion yang tertarik ke Ion H+, ion K+ Ion H+, ion Cu2+
katod
Ion that is selectively H+ ions Cu2+ ions
discharged at cathode Ion H+ Ion Cu2+
Ion yang dipilih untuk
dinyahcas di katod
Reason H+ ions is below K+ ions in Cu2+ ions is below H+ ions in
Sebab electrochemical series electrochemical series
Ion H+ berada di bawah ion Ion Cu2+ berada di bawah
K+ dalam siri elektrokimia ion H+ dalam siri
elektrokimia
Observation Gas bubbles are produced. Brown solid is deposited.
Pemerhatian Colourless gas are collected Pepejal perang terenap.
Example/Contoh:
Electrolysis by using hydrochloric acid with different concentration of ions. Complete the
table.
Elektrolisis menggunakan asid hidroklorik yang berbeza kepekatan. Lengkapkan jadual di
bawah.
Ions attracted to the anode Cl- ions, OH- ions Cl- ions, OH- ions
Ion-ion yang tertarik ke Ion Cl-, ion OH- Ion Cl-, ion OH-
anod
Ion that is selectively OH- ions Cl- ions
discharged at the anode Ion OH- Ion Cl-
Ion yang dipilih untuk
dinyahcas di anod
Reason OH- ion is lower than Cl- ion Concentration of Cl- ions is
Sebab in electrochemical series higher
Ion OH- adalah di bawah ion Kepekatan ion Cl- adalah
Cl- dalam siri elektrokimia lebih tinggi
An electrolysis is carried out to the following solutions using carbon electrodes. Complete
the
table.
Elektrolisis dijalankan pada larutan-larutan yang berikut dengan menggunakan elektrod
karbon. Lengkapkan jadual.
Example/Contoh:
Electrolysis of silver nitrate solution by using different types of electrodes. Complete the
table below.
Elektrolisis larutan argentum nitrat dengan menggunakan jenis elektrod yang berbeza.
Lengkapkan jadual bawah.
ELECTROLYSIS IN INDUSTRY
ELEKTROLISIS DALAM INDUSTRI
EXTRACTION OF METAL
PENGEKSTRAKAN LOGAM
Explaination /Penerangan:
Aluminium oxide is mixed with cryolite, Na3AlF6. Cryolite is
Added to lower the melting point of aluminium oxide.
Aluminium oksida dicampurkan dengan kriolit, Na3AlF6. Kriolit
ditambah untuk merendahkan takat lebur aluminium oksida.
Carbon electrodes act as the anodes while the carbon lining acts
as the cathode.
Elektrod karbon bertindak sebagai anod manakala lapisan
karbon bertindak sebagai cathode.
Anode/Anod:
Half equation / Persamaan setengah : 2O2- O2 + 4e
Cathode / Katod:
Half equation / Persamaan setengah : Al3+ + 3e Al
At anode:
Di anod :
At cathode:
Copper Iron Di katod:
Kuprum spoon
Sudu besi Copper plate becomes Copper solid is deposited
thicker around the copper plate.
Kepingan kuprum menebal Pepejal kuprum terenap di
sekitar kepingan kuprum.
At anode:
Di anod:
CHEMICAL CELL
SEL KIMIA
3 Elctrons flow through the wire from magnesium ribbon to copper plate
Elektron mengalir melalui wayar dari pita magnesium ke kepingan kuprum
5 At the copper plate, hydrogen ions, H+ are selectively discharged by gaining electrons
to form hydrogen gas. This is because hydrogen ion, H+ is lower than magnesium
ion, Mg2+ and sodium ion, Na+ in the electrochemical series.
Pada kepingan kuprum, ion hydrogen, H+ dipilih untuk dinyahcas dengan menerima
electron untuk membentuk gas hydrogen. Hal ini adalah kerana ion hydrogen, H+
berada di bawah ion magnesium, Mg2+ dan ion natrium, Na+ dalam siri elektrokimia.
DANIELL CELL
SEL DANIELL
1 A zinc – copper cell or Daniell cell is an example of a voltaic cell
Sel zink – kuprum ialah contoh sel kimia.
2 Zinc sulphate solution and copper(II) sulphate solution are connected by a salt bridge
or
a porous pot.
Larutan zink sulfat dan laritan kuprum(II) sulfat dihubungkan dengan titian garam
atau
pasu berliang.
7 At copper plate, copper(II) ion, Cu2+ which is lower than hydrogen ion, H+ in the
electrochemical series will be selectively discharged to form copper atom by gaining
electrons.
Pada kepingan kuprum, ion kuprum(II), Cu2+ yang berada di bawah ion hydrogen, H+
dalam siri elektrokimia akan dipilih untuk dinyahcas dengan menerima electron untuk
membentuk atom kuprum.
2 Metal that is more electropositive acts as the negative terminal. This metal
is placed higher in the electrochemical series.
Logam yang lebih elektropositif bertindak sebagai terminal negatif.
Logam ini berada di bahagian atas siri elektrokimia.
3 The further apart the pair of metals in the electrochemical series, the greater
the potential difference produced.
Semakin jauh kedudukan pasangan logam dalam siri elektrokimia, semakin besar
nilai voltan yang dihasilkan.
4 When two electrodes of the same metal are used, there is no potential difference.
Hence
no electrical current will flow through the wire.
Apabila dua elektrod yang sama digunakan, tiada voltan dihasilkan. Maka tiada arus
elektrik mengalir melalui wayar
1 A metal which is higher in the electrochemical series is able to displace a metal below
in
the electrochemical series from its salt solution.
Logam yang berada di bahagian atas siri elektrokimia boleh menyesarkan logam yang
berada di bahagian bawah siri elektrokimia daripada larutan garamnya.
3 Example / Contoh :
Displacement of copper from copper(II) sulphate solution.
Penyesaran kuprum daripada larutan kuprum(II) sulfat.
9 Overall equation for the displacement reaction / Persamaan ion keseluruhan bagi
tindak
balas penyesaran ini:
Mg + Cu2+ Mg2+ + Cu
1 Metal that is more electropositive (placed higher in the electrochemical series) is able
to
displace metal that is less electropositive (placed lower in the electrochemical series)
from its salt solution.
Logam yang lebih elektropositif (berada di bahagian atas siri elektrokimia) boleh
menyesarkan logam yang kurang elektropositif (berada di bahagian bawah siri
elektrokimia) daripada larutan garamnya.
3 Copper cannot displace any metals from their salt solutions because it is placed at the
lowest position in the electrochemical series compared to other metals used.
Kuprum tidak boleh menyesarkan sebarang logam daripada larutan garam masing-
masing kerana kedudukan kuprum adalah paling rendah dalam siri elektrokimia
berbanding dengan logam-logam lain yang digunakan.
1 B 5 A 9 A 13 D 17 A 21 B
2 B 6 B 10 D 14 B 18 D 22 C
3 D 7 B 11 15 D 19 C 23
4 D 8 B 12 B 16 C 20 C 24 C
The further the distance between copper and other metals in the
Electrochemical Series, the higher the voltage.
Lebih jauh jarak antara kuprum dan logam lain dalam Siri
Elektrokimia, semakin tinggi nilai voltan.
(c) Copper/Cu, Zinc/Zn, Aluminium/Al, Magnesium/Mg 3
Kuprum/Cu, Zink/Zn, Aluminium/Al, Magnesium/Mg
(d) 1.0V 3
(e) The is no potential difference between the copper electrode, so no 3
electron transfer.
Tiada beza keupayaan antara elektrod kuprum, maka tiada
pemindahan electron.
Total mark 12